自生Mg_2Si颗粒增强Al基复合材料的组织细化被引量：17

Microstructure refinement of in-situ Mg_2Si/Al composites

在线阅读下载PDF

导出

摘要研究了Sr以及Ce Sr复合添加剂对Al/Mg2Si/Si自生复合材料凝固组织的影响规律。当Ce、Sr的加入量分别为1.0%和0.7%(质量分数)时,Mg2Si增强体以细小短棒状形态出现,其平均粒径为12μm,这比未经细化处理的Mg2Si增强体的平均粒径降低52%。同时,单位面积Mg2Si晶粒平均数量为未经细化处理时的4～6倍。单独加入Sr时,复合材料的组织细化则不如Ce Sr复合处理时的稳定。对相关机制的研究表明,上述细化元素对Mg、Si原子在合金熔体中扩散的不同程度的抑制是微观组织得以细化的根本原因。 The effect of Sr and Ce-Sr refiners on the microstructure of as-cast Al/Mg_2Si/Si in-situ composite was investigated. When the addition contents of element Ce and Sr are 1.0% and 0.7%(mass fraction) respectively, Mg_2Si reinforcements exist in short rod-like shape, and the average size of Mg_2Si reinforcements can be reduced to 12 μm, which is 48% of that without refiners. Moreover, the average number per unit area of Mg_2Si reinforcements can increase by 46 times compared with the untreated one. The microstructure refinement effect of composites by Sr addition is less stable than that by Ce-Sr addition. Based on the mechanism analyses, it is concluded that the suppression of the diffusion of Mg and Si element by refiners contributes highly to the microstructure refinement.

作者李赤枫王俊李克疏达孙宝德

机构地区上海交通大学金属基复合材料国家重点实验室

出处《中国有色金属学报》 EI CAS CSCD 北大核心 2004年第2期233-237,共5页 The Chinese Journal of Nonferrous Metals

基金国家自然科学基金资助项目(50101005) 国家"863"计划资助项目(2002AA336072)

关键词铝基复合材料自生复合材料 MG2SI 组织细化凝固 Al-base composites in-situ composites Mg_2Si microstructure refinement

分类号 TB331 [一般工业技术—材料科学与工程]

引文网络
相关文献

参考文献7

1[2]ZHANG Jian,WANG Yu-qin,YANG Bing,et al.Effects of Si content on the microstructure and tensile strength of an in situ Al/Mg2Si composite[J].J Mater Res,1999,14(1):68-74.
2[4]ZHANG Jian,WANG Yu-qin,YANG Bing,et al.Microstructural refinement in Al-Mg2Si in-situ composites[J].J Mater Sci Lett,1999,18:783-784.
3[5]LI S P,ZHAO S X,PAN M X,et al.Eutectic reaction and microstructural characteristics of Al(Li)-Mg2Si alloys[J].J Mater Sci,2001,36:1569-1575.
4[6]Feufel H,Gdecke T,Lukas H L,et al.Investigation of Al-Mg-Si system by experiments and thermodynamic calculations[J].J Alloys Compounds,1997,247:31-42.
5[7]Mondolfo L F.Aluminum Alloy:Structure and Properties[M].London:Butterworth & Co (Publishers),Ltd,1976.
6[9]Chang J,Moon I,Choi C.Refinement of cast microstructure of hypereutectic Al-Si alloys through the addition of rare earth metals[J].J Mater Sci,1998,33:5015-5023.
7[10]Kyffin W J,Rainforth W M,Jones H.Effect of phosphorus additions on the spacing between primary silicon particles in a Bridgman solidified hypereutectic Al-Si alloy[J].J Mater Sci,2001,36:2667-2672.