摘要
针对某印染厂生产废水,以COD和色度为指标,用混凝试验方法研究了新型复合混凝脱色剂SE对印染废水的处理效果,并探讨了SE投加量及pH值、沉淀时间、搅拌强度对其混凝效果的影响,利用SE与PAC和PFS进行了对比试验.结果表明,SE可有效地去除印染废水中的COD和色度,当pH为8-10、沉淀时间为30 min、搅拌强度为75 r/min、投药量为155 mg/L时,去除效果最佳,COD和色度的去除率最高可达83%、94%;相对于PAC和PFS,SE产生的絮体大而密实,沉降速度快,产生污泥量少,药剂用量少,最佳出水水质为：COD为139 mg/L,色度为37.证明SE是印染废水处理高效实用的复合型混凝剂.
Research on the treatment efficiency and coagulation experiments was done using a new compound flocculation agent SE in printing and dyeing wastewater. Taking COD and chromaticity color as indexes, We did research on the coagulation efficiency under different condition of SE dosage, pH value, settling time, and agitation speed, and then we did comparative experiments between SE and PAC, SE and PFS. The experiments show that SE can effectively remove COD and chromaticity color. The four parameters namely pH of 8 - 10, settling of 30 min, agitation of 75 r/min and dosage of 155 mg/L were chosen, the COD and chromaticity color removal rate were recorded as high as 83% and 94% respectively, and the optimum effluent COD and chromaticity color were 155 mg/L and 37 respectively. Compared with PAC and PFS, SE produced bigger and more compact floc, settling time was shorter, the amount of mud and chemical dosage were less, and effluent quality was much better. The results show that SE is a high-effective and practical compound coagulant agent.
出处
《环境科学》
EI
CAS
CSCD
北大核心
2007年第6期1285-1289,共5页
Environmental Science
关键词
印染废水
混凝法
混凝脱色剂
printing and dyeing wastewater
coagulation method
flocculation agent
作者简介
范迪（1963～），男，博士研究生，高级工程师，主要研究方向为水处理。E-mml：fd0896@126．com
