摘要
该文研究芒硝基相变储能材料相变性能及其在青藏高原地区冬季简易温室的保温效果,采用物理法制备芒硝基复合相变储能材料,通过温度-时间曲线、差示扫描量热法(differential scanning calorimetry,DSC)和热常数分析仪(Hot Disk)等方法表征了材料性质。当添加成核剂硼砂质量分数为4%时,芒硝基复合相变材料的过冷度消失,添加增稠剂羧甲基纤维素钠质量分数1.5%时,芒硝基复合相变材料相分层现象基本消失,添加导热剂石墨粉质量分数为1%时,复合相变材料导热系数为1.0216 W/(m·K),材料相变潜热为127 k J/kg,放热峰值为15.4℃,同时经过300次相变循环,材料仍旧能保持较好的相变性能。芒硝基复合相变材料模拟在温室升温试验中表明:当芒硝基相变材料添加量为25、35和45 kg时清晨日出前最低温度可以提高1、3.6和4.4℃。分析相变材料温室石膏后墙结果表明:正午最高温度分别降低1.1、2.2和3.0℃,清晨日出前最低温度分别提高0.4、2.4和4.0℃。综合试验表明,该芒硝基复合相变材料适用于高寒气候环境下简易温室。
Thermal energy storage（TES） is considered as one of the most important energy storage methods, and it can reduce the imbalance between solar heat supply and consumption and help to save costs. The phase change materials（PCMs） are the materials storing and releasing latent heat during the phase change. Low temperature PCMs are widely used in greenhouse study. Glauber salt（Na SO4·10H2O） based composite PCMs affect the greenhouse temperature change directly and their phase change temperature is suitable for greenhouse application, but the problems of supercooling phase separation and low thermal conductivity exist in their application. Related studies have showed that borax is the best substance which can decrease the supercooling problem, and CMC（RnOCH2COONa） is effective to reduce their phase separation. In order to enhance its thermal conductivity, we chose graphitic material as the heat-removing agent. In this paper, we studied the properties of Glauber salt based phase change energy storage material and it＇s performance of heat storage in winter in the Qinghai-Tibet Plateau region. Firstly, we prepared the Glauber salt based composite PCMs in laboratory, and then their thermal properties were measured by the differential scanning calorimetry（DSC）. Samples were put in an alumina pan and heated from-10 to 40 ℃ at a rate of 1.0 ℃/min in purified nitrogen atmosphere（50 mL /min）. The thermal cycling tests were carried out in an oven（Themo SCIENTIFIC HAAKE A 40） by heating and cooling the samples from 10 to 40 ℃ repeatedly. Thermal conductivities were determined by the transient plane source（TPS） method（Hot Disk, TPS 2200）. The tested simple solar greenhouse was located in Xining City, Qinghai Province（101°44＇ E, 36°43＇ N）. It was 3.5 m long and 2.7 m wide. The wall included 5 cm flexible foam（polyurethane） and 20 cm gypsum brick, as well as 0.1 cm iron sheet. The test period was from December 20 th, 2015 to February 4th, 2016. The heat insulation sheet of the simple solar greenhouse was rolled up and down at 9：00 am and 5：00 pm on every sunny day, respectively. The temperatures of outdoor, and indoor air and gypsum wall, and solar irradiation were measured continuously at a time interval of 10 min. The data collected on a typical sunny day were used to study the heat-retaining properties in greenhouse with PCMs. When the temperature was higher than PCMs freezing and melting point, the PCMs released heat and froze. This paper explored the property about its undercooling, phase separation, thermal conductivity and phase change cycle. Two simple greenhouses were built, and the change of temperature was analyzed. Results showed that when adding the 4% borax（mass fraction）, the supercooling of PCMs almost disappeared; adding 1.5% CMC, the phase separation did not exist; adding 1% graphite powder, the thermal conductivity significantly improved. Latent heat of PCMs measured by DSC was 127 k J/kg. After the phase changing cycle of 300 times, PCMs still could keep good performance, which was suitable for greenhouse to keep warm in cold climate. The test results of greenhouse temperature showed that when the mass of phase change materials was 25, 35 and 45 kg, the lowest greenhouse temperature increased by 1, 3.6 and 4.4 ℃, respectively before sunrise in the morning. The test results also showed that when the mass of phase change materials was 25, 35 and 45 kg, the highest temperature of gypsum back wall in noon decreased by 1.1, 2.2 and 3.0 ℃ and the lowest temperature before sunrise in the morning increased by 0.4, 2.4 and 4.0 ℃ respectively compared with the contrast greenhouse. We can conclude that the adding of the PCMs can obviously increase the lowest temperature inside the greenhouse and the back wall, and it is suitable for solar greenhouse heating application in extremely cold climate environment.
出处
《农业工程学报》
EI
CAS
CSCD
北大核心
2016年第20期209-216,共8页
Transactions of the Chinese Society of Agricultural Engineering
基金
青海省国际合作资助项目(2014-HZ-820)
青海省重点实验室发展专项资金(2014-Z-Y31
2015-Z-Y02)
关键词
温室
温度
相变材料
简易温室
青藏高寒地区
十水硫酸钠
芒硝基相变材料
greenhouse
temperature
phase change materials
solar greenhouse
Qinghai-Tibet plateau
sodium sulfate decahydrate
glauber＇s salt-based phase change materials
作者简介
蒋自鹏，男，陕西汉中人，主要从事相变储能材料及技术研究。西宁青海大学新能源光伏产业研究中心，810016。Email：zipengjiang@163.com
通信作者：铁生年，男，青海西宁人，教授，主要从事新能源储能材料研究。西宁青海大学新能源光伏产业研究中心，810016。Email：tieshengnian@163．com
