A novel technology of preparation of felt-metal supported modified polyvinyl alcohol（PVA） ultrafiltration（UF） membrane was invented, which could avoid the blockage of the holes of support layer and the leakage of ...A novel technology of preparation of felt-metal supported modified polyvinyl alcohol（PVA） ultrafiltration（UF） membrane was invented, which could avoid the blockage of the holes of support layer and the leakage of the casting solution through the holes of support layer. Felt-metal supported ferric sulfate modified PVA composite UF membranes were prepared by the innovative technology. The results show that the composite membranes are used to treat 1 000 mg/L oil/water emulsion at trans-membrane pressure from 0.25 to 0.45 MPa, the permeate flux is from 36 to 52 L/（m2·h）, and the retention of chemical oxygen demand（COD） is over 92%. The composite membrane resistance increases with the increase of trans-naembrane pressure.展开更多
Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion va...Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion valence and pH value of electrolyte solution on the streaming potential(SP)of the membrane were investigated.The zeta potential and surface charge density of the membrane were calculated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory.The results indicate that the valence and concentration of cation have a greater influence on the SP and surface charge density of PS membrane than those of anion,and the pH value of electrolyte solution has great effects on the SP and zeta potential of the membrane surface. Both the absolute value of the streaming potential and water flux of the adsorbed membrane decrease,compared with those of the clean membrane.The streaming potential and flux of the cleaned membrane can be completely recovered by cleaning with the mass fraction of 0.8%EDTA at pH=10.展开更多
Polyethylene glycol(PEG) membranes with different molecular mass cut-offs were used to treat oil/water emulsion, and the effects of experimental conditions including pressure, temperature and different opera- ting mod...Polyethylene glycol(PEG) membranes with different molecular mass cut-offs were used to treat oil/water emulsion, and the effects of experimental conditions including pressure, temperature and different opera- ting modes on permeate flux and removal rate of chemical oxygen demand (COD_ Cr) were studied. The results show that the permeate flux of ultrafiltration membrane is influenced by pressure and temperature; practical pressure is chosen to be 0.30.7MPa for the PEG with molecular mass cut-offs of 8000 and 0.71.0 MPa for the PEG with molecular mass cut-offs of 2500; and the practical temperature is chosen to be 2532℃. Different operating modes of ultrafiltration also influence the permeate flux and removal rate of COD_ Cr. The ultrafiltration membrane of intermittent cross-flow operating mode is easier to be influenced by blocky polarization and contamination than that of sequential cross-flow operating mode. Removal rate of COD_ Cr in intermittent cross-flow and sequential cross-flow condition can be maintained at about 93%.展开更多
Metal-polyvinyl alcohol(PVA) composite ultrafiltration membranes were prepared by coating a certain concentration of PVA solution on metallic fiber sintered membranes. The effects of preparation conditions, such as th...Metal-polyvinyl alcohol(PVA) composite ultrafiltration membranes were prepared by coating a certain concentration of PVA solution on metallic fiber sintered membranes. The effects of preparation conditions, such as the coating solution concentration, sequence and times of coating, and heat-treatment on the properties of the composite membranes were studied. The results show that the hole diameter of the composite membrane decreases with the increase of the concentration of PVA, the hole diameter of composite membrane is different when the sequence of coating is different. When the higher concentration of PVA solution is used to coat the metallic membrane for the first time and the other smaller one for the second time, the hole diameter of the composite membrane is relatively small, compared with that of the composite membrane made by the smaller concentration of PVA solution for the first time and the other higher one for the second time. The holes of the composite membrane contract and the stability of the membrane is improved by heat treatment. When metal-PVA composite hydrophilic membranes are used to treat the oil/water emulsion with the concentration of 1 000 mg·L -1 , the retention is from 80% to 90%, and the permeate flux is from 15 L·m -2 ·h -1 to 40 L·m -2 ·h -1 at pressure of 0.2 to 0.3 MPa.展开更多
This pilot study involved the application of a crossflow ultrafiltration （UF） membrane module employing hollow fiber polysulphone membranes in the reclamation of protein and oligosaccharides from soy protein wastewa...This pilot study involved the application of a crossflow ultrafiltration （UF） membrane module employing hollow fiber polysulphone membranes in the reclamation of protein and oligosaccharides from soy protein wastewater. The optimal membrane molecular weight cut-off （MWCO） was selected as 10 ku upon retaining ratios of protein and oligosaccharides as well as the variation of permeate flux. The effects of pretreatment strategy and operating conditions, such as transmembrane pressure （TMP）, feed pH and velocity on flux were studied. According to the experimental result, the optimal operating conditions were determined as temperature 45 ℃, pH 4.5, TMP 0.2 MPa and feed velocity 10 L·s^-1. In addition, the permeate flux recovery by pure water backflushing and chemical cleaning was investigated. The experimental result showed that backflushing with pure water could only recover the lost permeate flux by 30%, and the decrease of backflushing interval was helpful in improving UF permeate productivity. Chemical cleaning test revealed that the combination of sodium hydroxide and EDTA was an ideal agent for cleaning the fouled membranes.展开更多
The pretreatment for the removal of small molecules from poly(acrylic acid) sodium (PAAS) solution by continuous diafiltration was investigated using ultrafiltration membrane. The effects of PAAS concentration, pH, tr...The pretreatment for the removal of small molecules from poly(acrylic acid) sodium (PAAS) solution by continuous diafiltration was investigated using ultrafiltration membrane. The effects of PAAS concentration, pH, trans-membrane pressure and pretreatment time on the permeate concentration and permeate flux were studied. The results show that the necessary pretreatment time (NPT) increases with PAAS concentration, decreases with TMP. The change trend of permeate flux with time is affected by pH. The permeate fluxes rapidly decrease from the start, and then increase gradually to stable values at pH 5.0, pH 7.0 and pH 9.3. However, it decreases gradually with time till a state value at pH 3.0 (iso-electric point, IEP). The removal of small molecules is easy at pH greater than iso-electric point (IEP). The change of filtration potential with time indicates the similar trend to that of permeation concentration, but the former is more convenient for indication of NPT.展开更多
The human plasma protein binding of water soluble flavonoids in the peels of five spices of citrus fruits was studied by ultrafiltration combined with HPLC.The flavonoids were extracted separately by hot and cold wate...The human plasma protein binding of water soluble flavonoids in the peels of five spices of citrus fruits was studied by ultrafiltration combined with HPLC.The flavonoids were extracted separately by hot and cold water,and higher total flavonoid contents were detected in the former extracts than the latter ones.All the extracts show significant scavenging abilities to both ABTS and DPPH free radicals,which indicates the health benefits of the water extracts of citrus fruits peels.For DPPH radical,the IC50values of hot extract follow as Navel orange(NO)≈Mandarin orange(MO)< Lemon(LE)< Lo tangerine(LO)< Pomelo(PO),while the rank is NO< PO<LE≈MO<LO for ABTS radical.The HPLC results reveal that the kinds and contents of the flavonoids detected in the extracts are different among the species.MO extract has the most neohesperidin dihydrochalcone of 118.76 μmol/L and quercetrin of 211.81 μmol/L of which are much more than the rest extracts.Pomelo extract has the most plentiful flavonoids of naringin with a concentration of 303.28 μmol/L.The high contents of myricetrin and dihydromyricetin which both are potent free radical scavengers may explain the highest free radical scavenging activity of the NO extract.The plasma binding rates decrease with the increasing concentrations of flavonoids,and the flavonoids having plenty hydroxyl groups on both A ring and B ring of the molecular skeleton have relative higher plasma binding rates.In addition,the plasma binding rates of flavonoids with saturated C3-C4 bond decrease significantly with the increasing concentrations.展开更多
To further utilize bioactive substance such as bovine colostrum sIgA and IgG, sIgA and IgG were isolated and purified simultaneously by salting out, ultrafiltration and gel chromatography, etc. The analysis of results...To further utilize bioactive substance such as bovine colostrum sIgA and IgG, sIgA and IgG were isolated and purified simultaneously by salting out, ultrafiltration and gel chromatography, etc. The analysis of results were showed quantitatively by nonhydrogenized SDS-PAGE, and quanlities of sIgA and IgG were respectively detected by Western Blot. The results showed that the purity and yield of bovine colostrum sIgA were 85.3% and 42.8%, respectively, while the purity and yield of bovine colostrum IgG were respectively 97.2% and 64.4%. This preparative method provides theoretical and experimental foundation for sIgA industrial production.展开更多
sIgA in bovine colostrum was purified by ultrafiltration and enzymolysis methods in this experiment, and the prepared substance was detected by Western Blot. The purity and yield were up to 73.6% and 65.2%, respective...sIgA in bovine colostrum was purified by ultrafiltration and enzymolysis methods in this experiment, and the prepared substance was detected by Western Blot. The purity and yield were up to 73.6% and 65.2%, respectively. This convenient technique offers helpful exploration for production of bovine colostrum sIgA展开更多
Colloid concentrates were obtained by employing a cross flow filtration system to ultrafiltrate seawater(which was pre filtrated by 0 45 μm acetate cellulose membrane) sucessively with three membranes.The retentio...Colloid concentrates were obtained by employing a cross flow filtration system to ultrafiltrate seawater(which was pre filtrated by 0 45 μm acetate cellulose membrane) sucessively with three membranes.The retentions (colloid concentrates) and control sample(in which colloid was removed)were then inoculated with a microalga and cultivated in vitro.After continuously monitoring cell content during cultivation,it was found that colloid had an obvious beneficial effect on the growth of microalga.Although colloids with different sizes influenced microalga's growth in different extent and ways,a brief conclusion could be draw from experiments that colloid might be a potential nutrition source for microalga's growth.展开更多
文摘A novel technology of preparation of felt-metal supported modified polyvinyl alcohol（PVA） ultrafiltration（UF） membrane was invented, which could avoid the blockage of the holes of support layer and the leakage of the casting solution through the holes of support layer. Felt-metal supported ferric sulfate modified PVA composite UF membranes were prepared by the innovative technology. The results show that the composite membranes are used to treat 1 000 mg/L oil/water emulsion at trans-membrane pressure from 0.25 to 0.45 MPa, the permeate flux is from 36 to 52 L/（m2·h）, and the retention of chemical oxygen demand（COD） is over 92%. The composite membrane resistance increases with the increase of trans-naembrane pressure.
基金Project(20776161)supported by the National Natural Science Foundation of China
文摘Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion valence and pH value of electrolyte solution on the streaming potential(SP)of the membrane were investigated.The zeta potential and surface charge density of the membrane were calculated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory.The results indicate that the valence and concentration of cation have a greater influence on the SP and surface charge density of PS membrane than those of anion,and the pH value of electrolyte solution has great effects on the SP and zeta potential of the membrane surface. Both the absolute value of the streaming potential and water flux of the adsorbed membrane decrease,compared with those of the clean membrane.The streaming potential and flux of the cleaned membrane can be completely recovered by cleaning with the mass fraction of 0.8%EDTA at pH=10.
文摘Polyethylene glycol(PEG) membranes with different molecular mass cut-offs were used to treat oil/water emulsion, and the effects of experimental conditions including pressure, temperature and different opera- ting modes on permeate flux and removal rate of chemical oxygen demand (COD_ Cr) were studied. The results show that the permeate flux of ultrafiltration membrane is influenced by pressure and temperature; practical pressure is chosen to be 0.30.7MPa for the PEG with molecular mass cut-offs of 8000 and 0.71.0 MPa for the PEG with molecular mass cut-offs of 2500; and the practical temperature is chosen to be 2532℃. Different operating modes of ultrafiltration also influence the permeate flux and removal rate of COD_ Cr. The ultrafiltration membrane of intermittent cross-flow operating mode is easier to be influenced by blocky polarization and contamination than that of sequential cross-flow operating mode. Removal rate of COD_ Cr in intermittent cross-flow and sequential cross-flow condition can be maintained at about 93%.
文摘Metal-polyvinyl alcohol(PVA) composite ultrafiltration membranes were prepared by coating a certain concentration of PVA solution on metallic fiber sintered membranes. The effects of preparation conditions, such as the coating solution concentration, sequence and times of coating, and heat-treatment on the properties of the composite membranes were studied. The results show that the hole diameter of the composite membrane decreases with the increase of the concentration of PVA, the hole diameter of composite membrane is different when the sequence of coating is different. When the higher concentration of PVA solution is used to coat the metallic membrane for the first time and the other smaller one for the second time, the hole diameter of the composite membrane is relatively small, compared with that of the composite membrane made by the smaller concentration of PVA solution for the first time and the other higher one for the second time. The holes of the composite membrane contract and the stability of the membrane is improved by heat treatment. When metal-PVA composite hydrophilic membranes are used to treat the oil/water emulsion with the concentration of 1 000 mg·L -1 , the retention is from 80% to 90%, and the permeate flux is from 15 L·m -2 ·h -1 to 40 L·m -2 ·h -1 at pressure of 0.2 to 0.3 MPa.
基金Mega-Projects of S&T Research for the 10th Five- Year Plan from Ministry of S&T of the People’s Republic of China(2001BA501A02B) Shenzhen S&T Tri- item Foundation (S040145)
文摘This pilot study involved the application of a crossflow ultrafiltration （UF） membrane module employing hollow fiber polysulphone membranes in the reclamation of protein and oligosaccharides from soy protein wastewater. The optimal membrane molecular weight cut-off （MWCO） was selected as 10 ku upon retaining ratios of protein and oligosaccharides as well as the variation of permeate flux. The effects of pretreatment strategy and operating conditions, such as transmembrane pressure （TMP）, feed pH and velocity on flux were studied. According to the experimental result, the optimal operating conditions were determined as temperature 45 ℃, pH 4.5, TMP 0.2 MPa and feed velocity 10 L·s^-1. In addition, the permeate flux recovery by pure water backflushing and chemical cleaning was investigated. The experimental result showed that backflushing with pure water could only recover the lost permeate flux by 30%, and the decrease of backflushing interval was helpful in improving UF permeate productivity. Chemical cleaning test revealed that the combination of sodium hydroxide and EDTA was an ideal agent for cleaning the fouled membranes.
基金Projects(21176264,21476265)supported by the National Natural Science Foundation of China
文摘The pretreatment for the removal of small molecules from poly(acrylic acid) sodium (PAAS) solution by continuous diafiltration was investigated using ultrafiltration membrane. The effects of PAAS concentration, pH, trans-membrane pressure and pretreatment time on the permeate concentration and permeate flux were studied. The results show that the necessary pretreatment time (NPT) increases with PAAS concentration, decreases with TMP. The change trend of permeate flux with time is affected by pH. The permeate fluxes rapidly decrease from the start, and then increase gradually to stable values at pH 5.0, pH 7.0 and pH 9.3. However, it decreases gradually with time till a state value at pH 3.0 (iso-electric point, IEP). The removal of small molecules is easy at pH greater than iso-electric point (IEP). The change of filtration potential with time indicates the similar trend to that of permeation concentration, but the former is more convenient for indication of NPT.
基金Project(21176263) supported by the National Natural Science Foundation of China
文摘The human plasma protein binding of water soluble flavonoids in the peels of five spices of citrus fruits was studied by ultrafiltration combined with HPLC.The flavonoids were extracted separately by hot and cold water,and higher total flavonoid contents were detected in the former extracts than the latter ones.All the extracts show significant scavenging abilities to both ABTS and DPPH free radicals,which indicates the health benefits of the water extracts of citrus fruits peels.For DPPH radical,the IC50values of hot extract follow as Navel orange(NO)≈Mandarin orange(MO)< Lemon(LE)< Lo tangerine(LO)< Pomelo(PO),while the rank is NO< PO<LE≈MO<LO for ABTS radical.The HPLC results reveal that the kinds and contents of the flavonoids detected in the extracts are different among the species.MO extract has the most neohesperidin dihydrochalcone of 118.76 μmol/L and quercetrin of 211.81 μmol/L of which are much more than the rest extracts.Pomelo extract has the most plentiful flavonoids of naringin with a concentration of 303.28 μmol/L.The high contents of myricetrin and dihydromyricetin which both are potent free radical scavengers may explain the highest free radical scavenging activity of the NO extract.The plasma binding rates decrease with the increasing concentrations of flavonoids,and the flavonoids having plenty hydroxyl groups on both A ring and B ring of the molecular skeleton have relative higher plasma binding rates.In addition,the plasma binding rates of flavonoids with saturated C3-C4 bond decrease significantly with the increasing concentrations.
文摘To further utilize bioactive substance such as bovine colostrum sIgA and IgG, sIgA and IgG were isolated and purified simultaneously by salting out, ultrafiltration and gel chromatography, etc. The analysis of results were showed quantitatively by nonhydrogenized SDS-PAGE, and quanlities of sIgA and IgG were respectively detected by Western Blot. The results showed that the purity and yield of bovine colostrum sIgA were 85.3% and 42.8%, respectively, while the purity and yield of bovine colostrum IgG were respectively 97.2% and 64.4%. This preparative method provides theoretical and experimental foundation for sIgA industrial production.
基金the Science and Technology Foundation of Heilongjiang Province (GA06B201-4)
文摘sIgA in bovine colostrum was purified by ultrafiltration and enzymolysis methods in this experiment, and the prepared substance was detected by Western Blot. The purity and yield were up to 73.6% and 65.2%, respectively. This convenient technique offers helpful exploration for production of bovine colostrum sIgA
文摘Colloid concentrates were obtained by employing a cross flow filtration system to ultrafiltrate seawater(which was pre filtrated by 0 45 μm acetate cellulose membrane) sucessively with three membranes.The retentions (colloid concentrates) and control sample(in which colloid was removed)were then inoculated with a microalga and cultivated in vitro.After continuously monitoring cell content during cultivation,it was found that colloid had an obvious beneficial effect on the growth of microalga.Although colloids with different sizes influenced microalga's growth in different extent and ways,a brief conclusion could be draw from experiments that colloid might be a potential nutrition source for microalga's growth.
