The coupled effect of viscosity enhancing admixtures(VEA)and superplasticizer(SP)on the rheological behavior of cement paste was investigated in this work.Two types of VEAs,including hydroxypropyl methylcellulose(HPMC...The coupled effect of viscosity enhancing admixtures(VEA)and superplasticizer(SP)on the rheological behavior of cement paste was investigated in this work.Two types of VEAs,including hydroxypropyl methylcellulose(HPMC)and Welan gum,and two types of SPs,i.e.polycarboxylate(PCA)and polynaphthalenesulfonate(PNS)were used as admixtures for cement paste.Rheological curves of cement paste and simulated pore solution containing VEA and SP were tested.Simulated pore solution test results show that molecules of different SPs may generate different effects on the viscosity of VEA solutions.Hershel-Bulkley(H-B)model was used to fit rheological curve of cement paste.Strong interaction between PNS and HPMC was observed in this work.展开更多
An innovative technology,nitric acid pressure leaching of limonitic laterite ores,was proposed by our research team.The HNO3 regeneration is considerable significance for the improvement of the proposed technology and...An innovative technology,nitric acid pressure leaching of limonitic laterite ores,was proposed by our research team.The HNO3 regeneration is considerable significance for the improvement of the proposed technology and its commercial application,but it has not been systematically investigated.Herein,regenerating HNO3 from Ca(NO3)2 solution with low-cost H2SO4,and simultaneous synthesis of fibrous CaSO4·2H2O by-products were studied.As a theoretical basis,the solubility of CaSO4·2H2O in HNO3 medium is studied.It is concluded that the solubility of CaSO4·2H2O increases with increasing temperature or increasing HNO3 concentration,which has considerable guiding significance for the subsequent experimental research and analysis.Then,the effects of various factors on the residual Ca^2+ concentration of filtrate,the regenerated HNO3 concentration and the morphology of synthesized products are investigated using ICP-AES and SEM.And the effect mechanism is also analyzed.The results indicate the regenerated HNO3 concentration reaches 116 g/L with the residual Ca^2+ concentration being 9.7 g/L at the optimum conditions.Moreover,fibrous CaSO4·2H2O by-products with high aspect ratios(length,406.32μm;diameter,14.71μm;aspect ratio,27.62)can be simultaneously synthesized.展开更多
The stress corrosion crack （SCC） susceptibility of ultra-high strength steel AerMet 100 was investigated by slow strain rate technique （SSRT）, tensile with polarization and surface analysis technique. The curves o...The stress corrosion crack （SCC） susceptibility of ultra-high strength steel AerMet 100 was investigated by slow strain rate technique （SSRT）, tensile with polarization and surface analysis technique. The curves of tf^Cl/tf^W -strain rate are divided into three regions： stress-dominated region, SCC-dominated region, and corrosion-dominated region, so as the curves of εf^Cl/εf^W - strain rate and tm/tf-strain rate. The results of tensile tests with polarization show that the main SCC mechanism of AerMet 100 is anodic dissolution, which controls the corrosion process. The three regions have been discussed according to the relationship between the rate of slip-step formation and the rate of dissolution. Fracture appearances in different environments were analyzed by scanning electron microscopy （SEM）. SCC fracture appears as a mixture of intergranular and dimples, while it is totally dimples in the inert environment. The εf becomes the parameter to predict tf because the relationship between εf^Cl/εf^W and tf^Cl/tf^w is a straight line for AerMet 100.展开更多
Excess lithium in alumina is significantly bad for aluminum reduction.In this study,the concentration variation of lithium ion in sodium aluminate solution with addition of synthetic lithium aluminate was investigated...Excess lithium in alumina is significantly bad for aluminum reduction.In this study,the concentration variation of lithium ion in sodium aluminate solution with addition of synthetic lithium aluminate was investigated.Elevating temperature,increasing caustic soda concentration,reducing alumina concentration or raising molar ratioαk improved equilibrium concentration of lithium ion in sodium aluminate solution.Agitation speed had a minimal effect on lithium ion concentration.Over 0.65 g/L lithium ion equilibrium concentration was observed in digestion process,whereas 35 mg/L lithium ion concentration remained in solution after precipitation time of 9 h.Moreover,equilibrium concentration decreased sharply from digestion of boehmite or diaspore to seed precipitation,about 95%lithium was precipitated into red mud(bauxite residue)and aluminum hydroxide.This study provides a valuable perspective in removal or extraction of lithium from sodium aluminate solution in alumina refineries.展开更多
Based on the characteristics of the lignite sample, effects of assistant anthraquinone （AQ） on extraction yield of humic substances （HS） and the action mechanisms of AQ in alkaline condition were studied by Fouvie...Based on the characteristics of the lignite sample, effects of assistant anthraquinone （AQ） on extraction yield of humic substances （HS） and the action mechanisms of AQ in alkaline condition were studied by Fouvier transform infrared （FT-IR） spectroscopy. The results indicate that assistant AQ can not only increase the extraction yield of HS but also reduce the alkali dosage （NaOH） as well as the extraction temperature and extraction time. Under the optimal conditions of alkali dosage of 9%, AQ dosage of 0.75%, extraction temperature of 80 ℃, extraction time of 30 min, stirring speed of 600 r/min and solid-to-liquid ratio of 1：3, the extraction yield of HS reaches 80.08%, which is increased by more than 20% compared with the conventional extraction. FT-IR spectra show that AQ is able to prevent dissolved HS from being destroyed into undissolved substance by alkali and 1-IS obtained in the presence of AQ possesses more groups of COOR and --COOH than that obtained without AQ.展开更多
Generation of polydisperse KCl aerosol with a new salt aerosol generator was investigated, Special attention was paid on particles with diameters between 3 and 10 μm. The main improvement consists of the different ro...Generation of polydisperse KCl aerosol with a new salt aerosol generator was investigated, Special attention was paid on particles with diameters between 3 and 10 μm. The main improvement consists of the different routes of KCl solution droplets. In traditional generators, the solution droplets travel through one cylinder; while in the case analyzed here, after spray atomization, the droplets travel through two cylinders in series. The first cylinder was fed with warm air and the second one with cold air. In such way, the complete evaporation of the water from the droplets can be ensured. The influencing factors of the generated aerosol size distribution were investigated. The data measured show that the concentration of generated aerosol becomes higher both increasing the flow rate of the KCI solution injected in the first cylinder and increasing the concentration in the solution. The temperature of solution influences mainly the generation of smaller KCI particles （0,3-3 μm）. The amount of hot air used in the generation process increases the concentration of larger KC1 particles （〉3 μm） while cold air does not have the same effect. The aerosol generator is able to generate KC1 aerosol stably. This instrument can be used effectively for testing air filters for automotive.展开更多
The removal of phosphate from aqueous solution by Donnan dialysis with anion-exchange membrane was investigated.The results show that phosphate could be removed from aqueous solution without supplying external high pr...The removal of phosphate from aqueous solution by Donnan dialysis with anion-exchange membrane was investigated.The results show that phosphate could be removed from aqueous solution without supplying external high pressure or electrical potential.Under the conditions of influent phosphate of 2.0 mg/L,counterion(Cl-)concentration of 0.1 mol/L,stirring speed of 500 r/min and phase temperature of 298 K,the removal of phosphate achieves 70.0%.Decreasing counterion concentration has little influence on the removal of phosphate,but phosphate amount in anion-exchange membrane increases significantly.With the increase of stirring speed and phase temperature,the removal efficiency of phosphate greatly is improved.Existing forms of phosphate in aqueous solution affected transport of phosphate and only strong acidic pH of feed solution(pH=3.0)decreases the removal of phosphate.Transport of phosphate is also accompanied by change of pH value of feed solution.In consequence,it might be a promise potential process for phosphate advanced wastewater treatment,especially in the area where high salted nature water can be utilized.展开更多
The streaming potential of poly（vinyl butyral） （PVB） hollow fiber membrane was studied in different electrolyte solutions （including NaCl, KCl, CaCl2 and MgCl2）, the effects of ionic strength, ion valence and pH...The streaming potential of poly（vinyl butyral） （PVB） hollow fiber membrane was studied in different electrolyte solutions （including NaCl, KCl, CaCl2 and MgCl2）, the effects of ionic strength, ion valence and pH value on the streaming potential （SP） of the membrane were investigated. The zeta potentials and surface charge densities of the membrane were estimated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory. The results show that the PVB membrane has a weak negative charge due to the specific adsorption of ions. Moreover, the streaming potential, the zeta potential and the surface charge density of the membrane depend strongly on the salt concentration and the type and valence of ions. The iso-electric point （IEP） of the PVB membrane is arotmd 3.0 in the monovalent media （NaC1 and KC1） and 3.5 in divalent electrolytes （CaCl2 and MgCl2）. A few retentions were obtained for PVB membrane in low concentration solutions. This result verifies that the negative charged membrane surface can reject inorganic solutes by means of electrostatic repulsion effect even though the size of membrane pores is much larger than the size of salts.展开更多
The effect of solution conditions on the depression of chlorite using CMC (carboxymethyl cellulose) as depressant was studied through flotation tests and adsorption measurements. Flotation and adsorption tests were fi...The effect of solution conditions on the depression of chlorite using CMC (carboxymethyl cellulose) as depressant was studied through flotation tests and adsorption measurements. Flotation and adsorption tests were first studied as a function of initial solution conditions. The results show that electrostatic repulsion between CMC molecules and chlorite surface hinders the approach of the CMC molecules to the chlorite surface and CMC adsorbs to a great extent at high ionic concentration (10-4 mol/L ions as opposed to 0 mol/L ions) or low pH (3 as opposed to 9). The enhanced adsorption density is attributed to the decreased electrostatic repulsion between CMC and mineral surface. The solution condition that yielded the lowest initial adsorbed amount (0 mol/L ions, pH 9) was used as a reference to investigate the response of the adsorbed CMC layer to a switch in solution conditions after adsorption. The two kinds of solution switches (reducing the solution pH or increasing ionic concentration) result in an increased depression effect of CMC on chlorite flotation, as a result of conformational change of CMC pre-adsorbed layer. The change in the flotation recovery of the CMC-coated chlorite following the solution switches is reversible.展开更多
Hydrogen sulfide in rural biogas was removed with liquid-phase catalytic oxidation.By using rare earth as catalyst,and sulfosalicylic acid as stabilizer,H2S purification efficiency could increase as high as 96%,and su...Hydrogen sulfide in rural biogas was removed with liquid-phase catalytic oxidation.By using rare earth as catalyst,and sulfosalicylic acid as stabilizer,H2S purification efficiency could increase as high as 96%,and sulfur capacity of the composite solution was about 3 g/L.The results show that purification efficiency was affected by catalyst addition,pH,experimental temperature,and sulfur capacity.The parameters effects on catalytic oxidation were studied,and the optimized conditions were that Fe3+ concentration 0.08 mg/L,reaction temperature 70°C,pH 9.0,with a absorption solution volume of 50 mL,a gas flow rate 200 mL/min,and H2S mass concentration of 1.58-2.02 mg/m3.展开更多
The leaching kinetics of low-grade copper ore with high-alkality gangues was studied in ammonia-ammonium sulphate solution.The main parameters,such as ammonia and ammonium sulphate concentrations,particle size,solid-t...The leaching kinetics of low-grade copper ore with high-alkality gangues was studied in ammonia-ammonium sulphate solution.The main parameters,such as ammonia and ammonium sulphate concentrations,particle size,solid-to-liquid ratio and reaction temperature,were chosen in the experiments.The results show that the increase of temperature,concentrations of ammonia and ammonium sulphate is propitious to the leaching rate of copper ore.The leaching rate increases with the decrease of particle size and solid-to-liquid ratio.The leaching rate is controlled by the diffusion through the ash layer and the activation energy is determined to be 25.54 kJ/mol.A semi-empirical equation was proposed to describe the leaching kinetics.展开更多
The extraction of zinc from zinc sulfate solution was investigated, using 20% saponified D2EHPA as an extractam and 260^# sulfonate kerosene as a diluent. The solution was stirred for 8 min at phase ratio （Vσ/Va） o...The extraction of zinc from zinc sulfate solution was investigated, using 20% saponified D2EHPA as an extractam and 260^# sulfonate kerosene as a diluent. The solution was stirred for 8 min at phase ratio （Vσ/Va） of 1.0：1.0, initial pH of 2.0 and stirring speed of 200 r/min. The results show that 75% zinc can be extracted from the zinc sulfate solution when the concentration of zinc is 18.7 g/L after being settled for 10 min. 88.60% zinc can be stripped by 196 g/L sulfuric acid, and zinc ion can be separated from ferric ion.展开更多
Nucleation mechanism and technological process for Ni-Fe co-deposition with a relatively high Fe^(2+)concentration surrounded were described,and the effects of Fe^(2+) concentration,solution pH,temperature,and sodium ...Nucleation mechanism and technological process for Ni-Fe co-deposition with a relatively high Fe^(2+)concentration surrounded were described,and the effects of Fe^(2+) concentration,solution pH,temperature,and sodium dodecyl sulfonate concentration were investigated.Electrochemical experiments demonstrate that iron's electrodeposition plays a leading role in the Ni-Fe co-deposition process,and the co-deposition nucleation mechanism accords with a progressive nucleation.Temperature increase does favor in increasing nickel content in the ferronickel(Ni-Fe co-deposition products),while Fe^(2+) concentration increase does not.When solution pH is higher than 3.5,nickel content in the ferronickel decreases with pH because of the hydrolysis of Fe^(2+).With the current density of 180 A/m^2,Na_2SO_4 concentration of 100 g/L and Ni^(2+) concentration of 60 g/L,a smooth ferronickel deposit containing 96.21% Ni can be obtained under the conditions of temperature of 60 °C,Fe^(2+) concentration of 0.3 g/L,solution pH of 3 and sodium dodecyl sulfonate concentration of 40 mg/L.展开更多
Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion va...Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion valence and pH value of electrolyte solution on the streaming potential(SP)of the membrane were investigated.The zeta potential and surface charge density of the membrane were calculated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory.The results indicate that the valence and concentration of cation have a greater influence on the SP and surface charge density of PS membrane than those of anion,and the pH value of electrolyte solution has great effects on the SP and zeta potential of the membrane surface. Both the absolute value of the streaming potential and water flux of the adsorbed membrane decrease,compared with those of the clean membrane.The streaming potential and flux of the cleaned membrane can be completely recovered by cleaning with the mass fraction of 0.8%EDTA at pH=10.展开更多
The effects of root oxidization ability and P fertilization on As mobility in soils, and subsequently As uptake, translocation and speciation in rice plants were investigated. Results show that root oxidation signific...The effects of root oxidization ability and P fertilization on As mobility in soils, and subsequently As uptake, translocation and speciation in rice plants were investigated. Results show that root oxidation significantly influences As mobility in rhizoshphere.Genotype TD71 with higher radial oxygen loss(ROL) induces more Fe plaque formation and sequesters more As and P in iron plaque and rhizoshphere soil, leading to the reduction of As accumulation in rice plants. Additionally, P addition mobilizes As in soil solution, and increases As accumulation in rice plants. Arsenic speciation results show that the majority of As species in husks detected is inorganic As, accounting for 82%-93% of the total As, while in grains the majority of As is inorganic As and dimethyl arsenic(DMA), with DMA accounting for 33%-64% of the total As. The fraction of inorganic As decreases while fraction of DMA increases, with increasing As and P concentrations. The study further elucidates the mechanisms involved in effects of ROL on As tolerance and accumulation in rice.展开更多
Needle-like crystals consisting of a solid solution of C(60)-C(70)fullerene were synthesized by a liquid-liquid interfacial precipitation method using toluene and 2-propanol as solvents.A machined crystal with a V-not...Needle-like crystals consisting of a solid solution of C(60)-C(70)fullerene were synthesized by a liquid-liquid interfacial precipitation method using toluene and 2-propanol as solvents.A machined crystal with a V-notch was placed in a focused ion beam scanning electron microscope where it was bent until fracture by pushing it with a molybdenum probe to measure its mechanical properties and its fracture surface was examined.The crystals had a tensile strength of 58-71 MPa,which is much higher than C60 fullerene needle-like crystals and slightly larger than alumina,and a fracture toughness of 1.1-1.3 MPa m(1/2).Moreover,it is possible to change the plasticity and fracture toughness of the C(60)-C(70)crystals by solvation of different numbers of fullerene molecules.The C(60)-C(70)fullerene crystals have the potential for use as electrodes,anchors for brittle materials,and ductile wires to carry electricity.展开更多
The reduction of Cr（Ⅵ） in aqueous solution by using bauxite ore was investigated.Experimental results for Cr（Ⅵ）reduction in aqueous solution depending on some factors such as time,sulfuric acid amount,bauxite do...The reduction of Cr（Ⅵ） in aqueous solution by using bauxite ore was investigated.Experimental results for Cr（Ⅵ）reduction in aqueous solution depending on some factors such as time,sulfuric acid amount,bauxite dosage,initial Cr（Ⅵ）concentration,formic acid concentration,daylight and temperature were presented.The obtained results show that sulfuric acid amount,bauxite dosage and initial Cr（Ⅵ） concentration of solution are most effective parameters on the reduction process.Also,it has been found that the 60 g/L of bauxite dosage is sufficient to reduce up to 100% of Cr（Ⅵ） from acidic solution under the condition of low initial Cr（Ⅵ） mass concentrations such as 10 mg/L.The reduction reaction is completed within 30 min at 25 ℃ under the experimental conditions：bauxite dosage of 60 g/L,amount of sulfuric acid 40-60 stoichiometric and initial mass concentration of Cr（Ⅵ）,10 mg/L.It was determined that reduction percentage is decreasing with increasing initial Cr（Ⅵ） concentration.The chemical oxygen demand of bauxite ore was found to be 26 mg COD/g.展开更多
Invading track of chloride ions and chloride ion distribution rule in cement-based materials were investigated by partially soaking in 3.5% （mass fraction） NaCl solution and fully immerging in 3.5% and 5.0% （mass f...Invading track of chloride ions and chloride ion distribution rule in cement-based materials were investigated by partially soaking in 3.5% （mass fraction） NaCl solution and fully immerging in 3.5% and 5.0% （mass fraction） NaC1 solution, respectively, and relevant invading mechanisms were discussed. Results indicate that under full immerging condition, the invading track of chloride ions in cement mortar is similar to beeline that is vertical to chloride ion invading direction, and chloride ion content decreases rapidly with the increase of chloride ion invading depth. Under partial soaking condition, the invading track of chloride ion in cement mortar is similar to the shape of concave parabola, and chloride ion content decreases slowly along the lengthway direction of cement mortar samples in the distance of 20-80 mm from the bottom. Lots of chloride ions accumulate in cement mortar surface layer under the effect of capillary rise and evaporation and then invade cement mortar by diffusion effect. Under partial soaking condition, cement mortar is distinguished by four areas, i.e., immerging area, wet area, crystallization area and dry area.展开更多
基金Project(2017YFB0310101)supported by National High Technology Research and Development Program of ChinaProject(51778269)supported by the National Natural Science Foundation of China
文摘The coupled effect of viscosity enhancing admixtures(VEA)and superplasticizer(SP)on the rheological behavior of cement paste was investigated in this work.Two types of VEAs,including hydroxypropyl methylcellulose(HPMC)and Welan gum,and two types of SPs,i.e.polycarboxylate(PCA)and polynaphthalenesulfonate(PNS)were used as admixtures for cement paste.Rheological curves of cement paste and simulated pore solution containing VEA and SP were tested.Simulated pore solution test results show that molecules of different SPs may generate different effects on the viscosity of VEA solutions.Hershel-Bulkley(H-B)model was used to fit rheological curve of cement paste.Strong interaction between PNS and HPMC was observed in this work.
基金Project(2182040)supported by the Beijing Natural Science Foundation,ChinaProjects(51674026,51974025,U1802253)supported by the National Natural Science Foundation of ChinaProject(FRF-TT-19-001)supported by the Fundamental Research Funds for the Central Universities,China。
文摘An innovative technology,nitric acid pressure leaching of limonitic laterite ores,was proposed by our research team.The HNO3 regeneration is considerable significance for the improvement of the proposed technology and its commercial application,but it has not been systematically investigated.Herein,regenerating HNO3 from Ca(NO3)2 solution with low-cost H2SO4,and simultaneous synthesis of fibrous CaSO4·2H2O by-products were studied.As a theoretical basis,the solubility of CaSO4·2H2O in HNO3 medium is studied.It is concluded that the solubility of CaSO4·2H2O increases with increasing temperature or increasing HNO3 concentration,which has considerable guiding significance for the subsequent experimental research and analysis.Then,the effects of various factors on the residual Ca^2+ concentration of filtrate,the regenerated HNO3 concentration and the morphology of synthesized products are investigated using ICP-AES and SEM.And the effect mechanism is also analyzed.The results indicate the regenerated HNO3 concentration reaches 116 g/L with the residual Ca^2+ concentration being 9.7 g/L at the optimum conditions.Moreover,fibrous CaSO4·2H2O by-products with high aspect ratios(length,406.32μm;diameter,14.71μm;aspect ratio,27.62)can be simultaneously synthesized.
基金Project(51171011) supported by the National Natural Science Foundation of China
文摘The stress corrosion crack （SCC） susceptibility of ultra-high strength steel AerMet 100 was investigated by slow strain rate technique （SSRT）, tensile with polarization and surface analysis technique. The curves of tf^Cl/tf^W -strain rate are divided into three regions： stress-dominated region, SCC-dominated region, and corrosion-dominated region, so as the curves of εf^Cl/εf^W - strain rate and tm/tf-strain rate. The results of tensile tests with polarization show that the main SCC mechanism of AerMet 100 is anodic dissolution, which controls the corrosion process. The three regions have been discussed according to the relationship between the rate of slip-step formation and the rate of dissolution. Fracture appearances in different environments were analyzed by scanning electron microscopy （SEM）. SCC fracture appears as a mixture of intergranular and dimples, while it is totally dimples in the inert environment. The εf becomes the parameter to predict tf because the relationship between εf^Cl/εf^W and tf^Cl/tf^w is a straight line for AerMet 100.
基金Project(2015BAB04B01)supported by the National Key Technology R&D Program of ChinaProject(FA2017029)supported by Science and Technology Program of Chongzuo,ChinaProject(CSUZC201811)supported by the Open-End Fund for the Valuable and Precision Instruments of Central South University,China
文摘Excess lithium in alumina is significantly bad for aluminum reduction.In this study,the concentration variation of lithium ion in sodium aluminate solution with addition of synthetic lithium aluminate was investigated.Elevating temperature,increasing caustic soda concentration,reducing alumina concentration or raising molar ratioαk improved equilibrium concentration of lithium ion in sodium aluminate solution.Agitation speed had a minimal effect on lithium ion concentration.Over 0.65 g/L lithium ion equilibrium concentration was observed in digestion process,whereas 35 mg/L lithium ion concentration remained in solution after precipitation time of 9 h.Moreover,equilibrium concentration decreased sharply from digestion of boehmite or diaspore to seed precipitation,about 95%lithium was precipitated into red mud(bauxite residue)and aluminum hydroxide.This study provides a valuable perspective in removal or extraction of lithium from sodium aluminate solution in alumina refineries.
基金Project(50725416) supported by the National Science Fund for Distinguished Young Scholars in ChinaProject(50804059) supported by the National Natural Science Foundation of China+1 种基金Project(2008BAB32B06) supported by the Key Program in National Science and Technology Pillar Program during the 11th Five-year Plan Period of ChinaProject(200805331080) supported by Specialized Research Fund for the Doctoral Program of Higher Education of China
文摘Based on the characteristics of the lignite sample, effects of assistant anthraquinone （AQ） on extraction yield of humic substances （HS） and the action mechanisms of AQ in alkaline condition were studied by Fouvier transform infrared （FT-IR） spectroscopy. The results indicate that assistant AQ can not only increase the extraction yield of HS but also reduce the alkali dosage （NaOH） as well as the extraction temperature and extraction time. Under the optimal conditions of alkali dosage of 9%, AQ dosage of 0.75%, extraction temperature of 80 ℃, extraction time of 30 min, stirring speed of 600 r/min and solid-to-liquid ratio of 1：3, the extraction yield of HS reaches 80.08%, which is increased by more than 20% compared with the conventional extraction. FT-IR spectra show that AQ is able to prevent dissolved HS from being destroyed into undissolved substance by alkali and 1-IS obtained in the presence of AQ possesses more groups of COOR and --COOH than that obtained without AQ.
基金Project(2010EME006) supported by Open Fund of the Key Laboratory of Environmental Medicine Engineering of Ministry of Education of China Project(51008063) supported by the National Natural Science Foundation of China+1 种基金 Project(3203000601) supported by the Postdoctoral Key Research Program from Southeast University, China Project(2011BAJ03B05) supported by the National Science and Technology Pillar Program during the 12th Five-Year Plan Period of China
文摘Generation of polydisperse KCl aerosol with a new salt aerosol generator was investigated, Special attention was paid on particles with diameters between 3 and 10 μm. The main improvement consists of the different routes of KCl solution droplets. In traditional generators, the solution droplets travel through one cylinder; while in the case analyzed here, after spray atomization, the droplets travel through two cylinders in series. The first cylinder was fed with warm air and the second one with cold air. In such way, the complete evaporation of the water from the droplets can be ensured. The influencing factors of the generated aerosol size distribution were investigated. The data measured show that the concentration of generated aerosol becomes higher both increasing the flow rate of the KCI solution injected in the first cylinder and increasing the concentration in the solution. The temperature of solution influences mainly the generation of smaller KCI particles （0,3-3 μm）. The amount of hot air used in the generation process increases the concentration of larger KC1 particles （〉3 μm） while cold air does not have the same effect. The aerosol generator is able to generate KC1 aerosol stably. This instrument can be used effectively for testing air filters for automotive.
基金Project(50778065)supported by the National Natural Science Foundation of China
文摘The removal of phosphate from aqueous solution by Donnan dialysis with anion-exchange membrane was investigated.The results show that phosphate could be removed from aqueous solution without supplying external high pressure or electrical potential.Under the conditions of influent phosphate of 2.0 mg/L,counterion(Cl-)concentration of 0.1 mol/L,stirring speed of 500 r/min and phase temperature of 298 K,the removal of phosphate achieves 70.0%.Decreasing counterion concentration has little influence on the removal of phosphate,but phosphate amount in anion-exchange membrane increases significantly.With the increase of stirring speed and phase temperature,the removal efficiency of phosphate greatly is improved.Existing forms of phosphate in aqueous solution affected transport of phosphate and only strong acidic pH of feed solution(pH=3.0)decreases the removal of phosphate.Transport of phosphate is also accompanied by change of pH value of feed solution.In consequence,it might be a promise potential process for phosphate advanced wastewater treatment,especially in the area where high salted nature water can be utilized.
基金Project(21176264)supported by the National Natural Science Foundation of ChinaProject(11JJ2010)supported by the Hunan Provincial Natural Science Foundation of China+1 种基金Project(CL11096)supported by the Undergraduate Innovation Training Foundation of Central South University,ChinaProject(BL12053)supported by the Undergraduate Innovation Training Foundation of Hunan Province,China
文摘The streaming potential of poly（vinyl butyral） （PVB） hollow fiber membrane was studied in different electrolyte solutions （including NaCl, KCl, CaCl2 and MgCl2）, the effects of ionic strength, ion valence and pH value on the streaming potential （SP） of the membrane were investigated. The zeta potentials and surface charge densities of the membrane were estimated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory. The results show that the PVB membrane has a weak negative charge due to the specific adsorption of ions. Moreover, the streaming potential, the zeta potential and the surface charge density of the membrane depend strongly on the salt concentration and the type and valence of ions. The iso-electric point （IEP） of the PVB membrane is arotmd 3.0 in the monovalent media （NaC1 and KC1） and 3.5 in divalent electrolytes （CaCl2 and MgCl2）. A few retentions were obtained for PVB membrane in low concentration solutions. This result verifies that the negative charged membrane surface can reject inorganic solutes by means of electrostatic repulsion effect even though the size of membrane pores is much larger than the size of salts.
基金Project(51174229) supported by the National Natural Science Foundation of China
文摘The effect of solution conditions on the depression of chlorite using CMC (carboxymethyl cellulose) as depressant was studied through flotation tests and adsorption measurements. Flotation and adsorption tests were first studied as a function of initial solution conditions. The results show that electrostatic repulsion between CMC molecules and chlorite surface hinders the approach of the CMC molecules to the chlorite surface and CMC adsorbs to a great extent at high ionic concentration (10-4 mol/L ions as opposed to 0 mol/L ions) or low pH (3 as opposed to 9). The enhanced adsorption density is attributed to the decreased electrostatic repulsion between CMC and mineral surface. The solution condition that yielded the lowest initial adsorbed amount (0 mol/L ions, pH 9) was used as a reference to investigate the response of the adsorbed CMC layer to a switch in solution conditions after adsorption. The two kinds of solution switches (reducing the solution pH or increasing ionic concentration) result in an increased depression effect of CMC on chlorite flotation, as a result of conformational change of CMC pre-adsorbed layer. The change in the flotation recovery of the CMC-coated chlorite following the solution switches is reversible.
基金Project(2008ZX07105-002) supported by the Erhai Lake Project of National Science and Technology Major Project in the 11th Five years Plan of China
文摘Hydrogen sulfide in rural biogas was removed with liquid-phase catalytic oxidation.By using rare earth as catalyst,and sulfosalicylic acid as stabilizer,H2S purification efficiency could increase as high as 96%,and sulfur capacity of the composite solution was about 3 g/L.The results show that purification efficiency was affected by catalyst addition,pH,experimental temperature,and sulfur capacity.The parameters effects on catalytic oxidation were studied,and the optimized conditions were that Fe3+ concentration 0.08 mg/L,reaction temperature 70°C,pH 9.0,with a absorption solution volume of 50 mL,a gas flow rate 200 mL/min,and H2S mass concentration of 1.58-2.02 mg/m3.
基金Project(2007CB613601) supported by the National Basic Research Program of ChinaProject(10C1095) supported by the Foundation of Hunan Educational Committee,China
文摘The leaching kinetics of low-grade copper ore with high-alkality gangues was studied in ammonia-ammonium sulphate solution.The main parameters,such as ammonia and ammonium sulphate concentrations,particle size,solid-to-liquid ratio and reaction temperature,were chosen in the experiments.The results show that the increase of temperature,concentrations of ammonia and ammonium sulphate is propitious to the leaching rate of copper ore.The leaching rate increases with the decrease of particle size and solid-to-liquid ratio.The leaching rate is controlled by the diffusion through the ash layer and the activation energy is determined to be 25.54 kJ/mol.A semi-empirical equation was proposed to describe the leaching kinetics.
基金Project(50774094) supported by the National Natural Science Foundation of China
文摘The extraction of zinc from zinc sulfate solution was investigated, using 20% saponified D2EHPA as an extractam and 260^# sulfonate kerosene as a diluent. The solution was stirred for 8 min at phase ratio （Vσ/Va） of 1.0：1.0, initial pH of 2.0 and stirring speed of 200 r/min. The results show that 75% zinc can be extracted from the zinc sulfate solution when the concentration of zinc is 18.7 g/L after being settled for 10 min. 88.60% zinc can be stripped by 196 g/L sulfuric acid, and zinc ion can be separated from ferric ion.
基金Project(51574135)supported by the National Natural Science Foundation of ChinaProject(KKPT201563022)supported by Collaborative Innovation Center of Kunming University of Science and Technology,China
文摘Nucleation mechanism and technological process for Ni-Fe co-deposition with a relatively high Fe^(2+)concentration surrounded were described,and the effects of Fe^(2+) concentration,solution pH,temperature,and sodium dodecyl sulfonate concentration were investigated.Electrochemical experiments demonstrate that iron's electrodeposition plays a leading role in the Ni-Fe co-deposition process,and the co-deposition nucleation mechanism accords with a progressive nucleation.Temperature increase does favor in increasing nickel content in the ferronickel(Ni-Fe co-deposition products),while Fe^(2+) concentration increase does not.When solution pH is higher than 3.5,nickel content in the ferronickel decreases with pH because of the hydrolysis of Fe^(2+).With the current density of 180 A/m^2,Na_2SO_4 concentration of 100 g/L and Ni^(2+) concentration of 60 g/L,a smooth ferronickel deposit containing 96.21% Ni can be obtained under the conditions of temperature of 60 °C,Fe^(2+) concentration of 0.3 g/L,solution pH of 3 and sodium dodecyl sulfonate concentration of 40 mg/L.
基金Project(20776161)supported by the National Natural Science Foundation of China
文摘Polysulfone(PS)hollow-fiber ultrafiltration membrane was characterized combined with flux and streaming potential in single electrolyte solutions.The effects of trans-membrane pressure,electrolyte concentration,ion valence and pH value of electrolyte solution on the streaming potential(SP)of the membrane were investigated.The zeta potential and surface charge density of the membrane were calculated on the basis of Helmholtz-Smoluchowski equation and Gouy-Chapmann theory.The results indicate that the valence and concentration of cation have a greater influence on the SP and surface charge density of PS membrane than those of anion,and the pH value of electrolyte solution has great effects on the SP and zeta potential of the membrane surface. Both the absolute value of the streaming potential and water flux of the adsorbed membrane decrease,compared with those of the clean membrane.The streaming potential and flux of the cleaned membrane can be completely recovered by cleaning with the mass fraction of 0.8%EDTA at pH=10.
基金Project(41201493)supported by the National Natural Science Foundation of ChinaProject(201109056)supported by Special Scientific Research of Environmental Protection for Public Welfare Industry,China
文摘The effects of root oxidization ability and P fertilization on As mobility in soils, and subsequently As uptake, translocation and speciation in rice plants were investigated. Results show that root oxidation significantly influences As mobility in rhizoshphere.Genotype TD71 with higher radial oxygen loss(ROL) induces more Fe plaque formation and sequesters more As and P in iron plaque and rhizoshphere soil, leading to the reduction of As accumulation in rice plants. Additionally, P addition mobilizes As in soil solution, and increases As accumulation in rice plants. Arsenic speciation results show that the majority of As species in husks detected is inorganic As, accounting for 82%-93% of the total As, while in grains the majority of As is inorganic As and dimethyl arsenic(DMA), with DMA accounting for 33%-64% of the total As. The fraction of inorganic As decreases while fraction of DMA increases, with increasing As and P concentrations. The study further elucidates the mechanisms involved in effects of ROL on As tolerance and accumulation in rice.
基金partly supported by the Center of Materials Research for Low Carbon Emission of National Institute for Materials Sciencethe Japan Society for the Promotion of Science KAKENHI(No.26600007)
文摘Needle-like crystals consisting of a solid solution of C(60)-C(70)fullerene were synthesized by a liquid-liquid interfacial precipitation method using toluene and 2-propanol as solvents.A machined crystal with a V-notch was placed in a focused ion beam scanning electron microscope where it was bent until fracture by pushing it with a molybdenum probe to measure its mechanical properties and its fracture surface was examined.The crystals had a tensile strength of 58-71 MPa,which is much higher than C60 fullerene needle-like crystals and slightly larger than alumina,and a fracture toughness of 1.1-1.3 MPa m(1/2).Moreover,it is possible to change the plasticity and fracture toughness of the C(60)-C(70)crystals by solvation of different numbers of fullerene molecules.The C(60)-C(70)fullerene crystals have the potential for use as electrodes,anchors for brittle materials,and ductile wires to carry electricity.
文摘The reduction of Cr（Ⅵ） in aqueous solution by using bauxite ore was investigated.Experimental results for Cr（Ⅵ）reduction in aqueous solution depending on some factors such as time,sulfuric acid amount,bauxite dosage,initial Cr（Ⅵ）concentration,formic acid concentration,daylight and temperature were presented.The obtained results show that sulfuric acid amount,bauxite dosage and initial Cr（Ⅵ） concentration of solution are most effective parameters on the reduction process.Also,it has been found that the 60 g/L of bauxite dosage is sufficient to reduce up to 100% of Cr（Ⅵ） from acidic solution under the condition of low initial Cr（Ⅵ） mass concentrations such as 10 mg/L.The reduction reaction is completed within 30 min at 25 ℃ under the experimental conditions：bauxite dosage of 60 g/L,amount of sulfuric acid 40-60 stoichiometric and initial mass concentration of Cr（Ⅵ）,10 mg/L.It was determined that reduction percentage is decreasing with increasing initial Cr（Ⅵ） concentration.The chemical oxygen demand of bauxite ore was found to be 26 mg COD/g.
基金Project(50678174) supported by the National Natural Science Foundation of China
文摘Invading track of chloride ions and chloride ion distribution rule in cement-based materials were investigated by partially soaking in 3.5% （mass fraction） NaCl solution and fully immerging in 3.5% and 5.0% （mass fraction） NaC1 solution, respectively, and relevant invading mechanisms were discussed. Results indicate that under full immerging condition, the invading track of chloride ions in cement mortar is similar to beeline that is vertical to chloride ion invading direction, and chloride ion content decreases rapidly with the increase of chloride ion invading depth. Under partial soaking condition, the invading track of chloride ion in cement mortar is similar to the shape of concave parabola, and chloride ion content decreases slowly along the lengthway direction of cement mortar samples in the distance of 20-80 mm from the bottom. Lots of chloride ions accumulate in cement mortar surface layer under the effect of capillary rise and evaporation and then invade cement mortar by diffusion effect. Under partial soaking condition, cement mortar is distinguished by four areas, i.e., immerging area, wet area, crystallization area and dry area.
