Coal sludge slurry(CSS) is an alternative fuel and a potential competitive method for sludge reduction.Based on the researches of coal water slurry, we studied CSSs by using a wet-grinding process with different types...Coal sludge slurry(CSS) is an alternative fuel and a potential competitive method for sludge reduction.Based on the researches of coal water slurry, we studied CSSs by using a wet-grinding process with different types of regional municipal sludge(sludge) in an orthogonal experiment. The sludge type,sludge mixing proportion, dosage of dispersant, and grinding time were tested in this study. The results show that water content and its occurrence characteristics in the sludge have primary hindering influences on slurry ability. The range of fixed-viscosity concentrations with raw wet sludge is from 50.78%to 44.40%(by weight), while the range is from 53.35% to 51.51%(by weight) with dry sludge. All of the CSSs exhibit shear-thinning behaviors with different variation trends, especially the CSSs with more than 15%(by weight) raw wet sludge in it. Adding the same proportion of raw wet sludge increases the thixotropic properties of CSSs and the highest area of thixotropy loop is 3065 Pa/s, while the highest value of dry sludge is 1798 Pa/s. Hydrophilic group plays an important role in adsorbing water and building three-dimension networks with other particles, which is the main reason for CSS properties.Therefore, the mechanism can be used to find the way for making high quality CSS.展开更多
In this study,an up-flow anaerobic sludge blanket(UASB) reactor was applied to treat the high salinity wastewater from heavy oil production process.At a HRT of ≥24 h,the COD removal reached as high as 65.08% at an in...In this study,an up-flow anaerobic sludge blanket(UASB) reactor was applied to treat the high salinity wastewater from heavy oil production process.At a HRT of ≥24 h,the COD removal reached as high as 65.08% at an influent COD ranging from 350mg/L to 640mg/L.An average of 74.33% oil reduction was also achieved in the UASB reactor at an initial oil concentration between 112mg/L and 205mg/L.These results indicated that this heavy oil production related wastewater could be degraded efficiently in the UASB reactor.Granular sludge was formed in this reactor.In addition,two models,built on the back propagation neural network(BPNN) theory and linear regression techniques were developed for the simulation of the UASB system performance in the oily wastewater biodegradation.The average error of COD and oil removal was-0.65% and 0.84%,respectively.The results indicated that the models built on the BPNN theory were wellfitted to the detected data,and were able to simulate and predict the removal of COD and oil by the UASB reactor.展开更多
Crude oil is a kind of water/oil emulsion, which the oil phase consists of organic molecules with different molecular weights such as alkanes, paraffin, asphaltene, and resins. Due to the change in physicochemical con...Crude oil is a kind of water/oil emulsion, which the oil phase consists of organic molecules with different molecular weights such as alkanes, paraffin, asphaltene, and resins. Due to the change in physicochemical conditions during the production, transportation, storage, and refining, heavier molecules can precipitate from crude oil. Thus, viscous sludge formed at the bottom of storage tanks can cause many problems including reduction of storage capacity of tank, oil contamination, corrosion, repair costs, environmental pollution, etc. The reduction of sludge viscosity can be achieved by reduction of its interfacial tension. In this study, different chemical and physical factors, influencing prepared emulsions（made of sludge, water and surfactant）, such as surfactants, solvents, temperature, pressure, and mixing conditions were investigated. Results showed that non-ionic surfactants（like bitumen emulsifier）, and solvents（such as mixed xylene, AW-400, and AW-402）, injection of additives, applying pressure, and mixing operations had a positive effect on reduction of emulsion viscosity. All experiments were carried out with sludge obtained from crude oil storage tanks at Kharg Island,Iran.展开更多
A study was carried out to determine the influence of different types of sludges （municipal, industrial and residential） on field germination, growth and nodulation of L. leucocephala seedlings in the nursery. Befor...A study was carried out to determine the influence of different types of sludges （municipal, industrial and residential） on field germination, growth and nodulation of L. leucocephala seedlings in the nursery. Before sowing of seeds, different combinations of sludges were incorporated with the nutrient deficient natural forest soils. Field germination, nodulation status and physical growth parameters of seedlings （shoot and root length, vigor index, collar diameter, leaf number, fresh and dry weight of shoot and root and total dry biomass increment） were recorded after three and six months of seed sowing. Field germination, nodulation status and growth parameters were varied significantly in the soil amended with sludges in comparison to control. The highest number of nodule was recorded from soil amended with residential sludge （ 1：1 ） and highest fresh and dry nodule weight was also found from the same combination in both three and six month old seedlings. In case of growth parameters, the highest growth was recorded from soil and residential sludge （ 1：1 ） combination compared to control. From the study, it can be recommended that soil amended with residential sludge （ 1：1 ） provide better field germination, growth and nodule formation of L. leucocephala in degraded soil.展开更多
The cost-effective treatment of activated sludge that is generated by refining petroleum is a challenging industrial problem.In this study, semi-continuous stirred tank reactors(CSTRs) containing petroleum refinery ex...The cost-effective treatment of activated sludge that is generated by refining petroleum is a challenging industrial problem.In this study, semi-continuous stirred tank reactors(CSTRs) containing petroleum refinery excess activated sludge(PREAS)were used to comparatively investigate hydrolysis and acidification rates, after the addition of heneicosane(C_(21)H_(44))(R1)and 1-phenylnaphthalene(C16 H12)(R2) to different and individual reactors. Operation of the reactors using a sludge retention time(SRT) of 6 days and a pH of 5.0, resulted in the maintenance of stable biological activity as determined by soluble chemical oxygen demand(SCOD), volatile fatty acids(VFAs) production and oil removal efficiency. The optimum conditions for hydrogen production include a SRT of 8 days, at pH 6.5. Under these conditions, hydrogen production rates in the control containing only PREAS were 1567 mL/L(R0), compared with 1365 mL/L in Rl and 1454 mL/L-PREAS in R2.Coprothermobacter, Fervidobacterium, Caldisericum and Tepidiphilus were the dominant bacterial genera that have the potential to degrade petroleum compounds and generate VFAs. This study has shown that high concentrations of heneicosane and 1-phenylnaphthalene did not inhibit the hydrolytic acidification of PREAS.展开更多
We used paper mill sludge（PMS） to substitute for part of the wood fibers（WF） used to reinforce high density polyethylene（HDPE）.The resulting composites were subjected to xenon-arc weathering.The composite filled...We used paper mill sludge（PMS） to substitute for part of the wood fibers（WF） used to reinforce high density polyethylene（HDPE）.The resulting composites were subjected to xenon-arc weathering.The composite filled with limited PMS（under 10 %） had mechanical properties and aging resistance similar to those without PMS.The composites containing more PMS faded and cracked more readily than those without PMS.Based on the carbonyl index,crystallinity,and wood index,PMS appeared to accelerate the degradation of composites during weathering.Adding PMS to WF–HDPE composites reduced the weathering resistance,and this reduction was not significant if the PMS content did not exceed 20 % of the wood fibers.Therefore,PMS could be used as a reinforcement in wood-plastic composites at levels less than20 % of the wood fiber content.展开更多
The disc-seal single screw pump(DSSP)used in the field of high viscosity oily sludge transport has a huge advantage.However,there is no research on the pressurization characteristics of the DSSP at present,which makes...The disc-seal single screw pump(DSSP)used in the field of high viscosity oily sludge transport has a huge advantage.However,there is no research on the pressurization characteristics of the DSSP at present,which makes its application limited.In view of this,the pressurization process mathematical model of the DSSP was established based on the geometric model of the pump.By using this model,the pressurization characteristics of DSSP and the influence of working parameters on the pressurization process were studied combined with the principle of back-flow pressurization.Analysis results show that the instantaneous pressurization process could be realized mainly depending on the reflux pressurization from the outlet chamber to the pressurization chamber when the screw rotor rotating angle is located at-5°to+5°.The pressure in the pressurization chamber will increase with the increase of working parameters which include inlet pressure,outlet pressure,screw rotation velocity and dynamic viscosity of fluid medium in the area of flow-back pressurization.The screw rotation velocity and the viscosity of the conveying medium have significant effects on the peak pressure in the pressurization chamber,and the peak pressure in the pressurization chamber is proportional to the screw rotation velocity and the dynamic viscosity coefficient of the conveying medium.The proportional coefficient between the peak pressure and the screw rotation velocity is 6.29×10~4.The proportional coefficient between the peak pressure and the dynamic viscosity of the conveying medium is 6.28×10~6.展开更多
Thermal plasma was applied for the treatment of coke wastewater sludge derived from the steel industry in order to investigate the feasibility of the safe treatment and energy recovery of the sludge. A 30 kW plasma to...Thermal plasma was applied for the treatment of coke wastewater sludge derived from the steel industry in order to investigate the feasibility of the safe treatment and energy recovery of the sludge. A 30 kW plasma torch system was applied to study the vitrification and gas production of coke wastewater sludge. Toxicity leaching results indicated that the sludge treated via the thermal plasma process converted into a vitrified slag which resisted the leaching of heavy metals. CO2 was utilized as working gas to study the production and heat energy of the syngas. The heating value of the gas products by thermal plasma achieved 8.43 k J/L, indicating the further utilization of the gas products. Considering the utilization of the syngas and recovery heat from the gas products, the estimated treatment cost of coke wastewater sludge via plasma torch was about 0.98 CNY/kg sludge in the experiment. By preliminary economic analysis, the dehydration cost takes an important part of the total sludge treatment cost. The treatment cost of the coke wastewater sludge with 50 wt.% moisture was calculated to be about 1.45 CNY/kg sludge dry basis. The treatment cost of the coke wastewater sludge could be effectively controlled by decreasing the water content of the sludge. These findings suggest that an economic dewatering pretreatment method could be combined to cut the total treatment cost in an actual treatment process.展开更多
A study was conducted to evaluate the effects of sludge （industrial and residential） on seed germination and growth performance of Acacia auriculiformis seedlings at the nursery of Institute of Forestry and Environm...A study was conducted to evaluate the effects of sludge （industrial and residential） on seed germination and growth performance of Acacia auriculiformis seedlings at the nursery of Institute of Forestry and Environmental Sciences, Chittagong University （IFESCU）, Bangladesh. Before sowing of the seeds, different combinations of sludge were incorporated with the nutrient-deficient natural forest soils. Seed germination and growth parameters of the seedlings （shoot and root length, collar diameter, fresh and dry weight of shoot, and root and total dry biomass） were recorded after one, two and three months of seed sowing. Physio-chemical parameters （pH, organic carbon, nitrogen, phosphorus, and potassium） and heavy metals （chromium, nickel, manganese, cadmium and zinc） of each treatment were also analyzed before sowing of seeds and after harvesting of seedlings. Results show that the seed germination percentage and the seedling growth parameters varied significantly in the soil added with sludge in comparison to control. The highest germination percentage （90%） was observed in the treatment of soil with residential sludge of 2：1 compared to control. The highest growth and biomass of the seedlings as well as the maximum percentage of organic carbon and nutrients （N, P and K） were also recorded in the same combination. Soil added with industrial sludge had a higher concentration of heavy metal than that of residential sludge. The highest concentrations of heavy metals were found in soil added with industrial sludge of 1：1. It is recommended that soil added with residential sludge of 2：1 provide good condition for better seed germination and growth ofA. auriculiformis seedlings in degraded forest soil.展开更多
Oily sludge was recognized as a kind of hazardous wastes,so recycling its high content of petroleum hydrocarbons can contribute to the clean environment.In this study,oily sludge was subjected to continous ultrasonic ...Oily sludge was recognized as a kind of hazardous wastes,so recycling its high content of petroleum hydrocarbons can contribute to the clean environment.In this study,oily sludge was subjected to continous ultrasonic extraction with an acetone/carbon disulfide(CS2)mixture solvent.Fourier transform infrared spectroscopy(FTIRS),gas chromatography/mass spectrometry(GC/MS),and Quadrupole exactive Orbitrap mass spectrometry(QPEOTMS)were used to analyze the oil phase compounds from oily sludge.The n-alkanes ranging from C8 to C31 hydrocarbons were detected in oil phase.Compared with the analysis results of GC/MS,more heteroatom-containing compounds(HACOCs)of oil phase such as O3,O4,N2Oo and N3Oo(o=0—3)could be detected by using the QPEOTMS analysis.Overall,these findings will potentially contribute to the clean and efficient utilization of oily sludge.展开更多
In this study, Mucuna flagellipes seed extract was applied in the coagulation-flocculation of produced water （PW）. Process parameters such as pH, dosage, and settling time were investigated. Process kinetics was als...In this study, Mucuna flagellipes seed extract was applied in the coagulation-flocculation of produced water （PW）. Process parameters such as pH, dosage, and settling time were investigated. Process kinetics was also studied. Instrumental characterization of mucuna seed （MS）, mucuna seed coagulant （MSC）, and post effluent treatment settled sludge （PTSS） were carried out. The optimum decontamination efficiency of 95 % was obtained at 1 g/L MSC dosage, PW pH of 2, and rate constant of 0.0001 （L/g/s）. Characterization results indicated that MS, MSC, and PTSS were of network structure, primitive lat- tice, and thermally stable. It could be concluded that MSC would be potential biomass for the treatment of produced water under the experimental conditions.展开更多
Safe and economical disposal of paper mill sludge is a key consideration for forest products industry. A study was conducted to examine the effects of amendments of sludge and nutrients on soil surface CO2 flux （Rs）...Safe and economical disposal of paper mill sludge is a key consideration for forest products industry. A study was conducted to examine the effects of amendments of sludge and nutrients on soil surface CO2 flux （Rs） in northern hardwood forests and to quantify the relationship among Rs, soil temperature, and moisture in these stands. The experiment was a randomized complete block design that included sludge-amended, fertilized, and control treatments in sugar maple （Acer saccharum Marsh） dominated hardwood forests in the Upper Peninsula of Michigan, USA. Results showed that Rs was positively correlated to soil temperature （R^2 = 0.80, p 〈 0.001）, but was poorly correlated to soil moisture. Soil moisture positively affected the Rs only in the sludge-amended treatment. The Rs was significantly greater in the sludge-amended treatment than in the fertilized （p = 0.033） and the control （p = 0.048） treatments. The maximum Rs in the sludge-amended treatment was 8.8 μmol CO2 · m^ 2. s^-1, 91% and 126% greater than those in the fertilized （4.6 μmol CO2 · m^-2· s^-1） and control （3.9 μmol CO2· m^- 2· s^-1） treatments, respectively. The Rs did not differ significantly between the fertilized and control treatments. The difference in Rs between sludge-amended and the other treatments decreased with time following treatment.展开更多
Polyhydroxyalkanoates（PHAs）were synthesized in activated sludge using three types of carbon sources（sodium acetate,sodium propionate and sodium butyrate）,and their characterization were studied.It was shown that t...Polyhydroxyalkanoates（PHAs）were synthesized in activated sludge using three types of carbon sources（sodium acetate,sodium propionate and sodium butyrate）,and their characterization were studied.It was shown that the content of PHA synthesized by microorganisms in activated sludge were different.The biggest synthetic amount up to 36.7% of VSS was obtained when sodium acetate was used as carbon source.The polymer yield was lower when using sodium propionate as the carbon source than when using others,with25.1% of VSS,while resulted in an increase of hydroxyvalerate（HV）units produced.The structure and thermal properties of extracted biopolymers were analyzed by scanning electron microscope（SEM）,Fourier transform infrared spectroscopy（FTIR）and themogravimetry（TG）.展开更多
A device to activate lignite and sludge by electro-hydraulic impulse is presented. It comprises an impulse current generator constituted by a high voltage transformer, a high voltage silicon rectifier, a current-limit...A device to activate lignite and sludge by electro-hydraulic impulse is presented. It comprises an impulse current generator constituted by a high voltage transformer, a high voltage silicon rectifier, a current-limiting resistor, a capacitor bank and an air-break switch, and a lignite and sludge appliance made up of two plane electrodes and a working chamber. The installation activates the lignite or sludge delivered to the working chamber by the impulse current that is from the generator to puncture the main gap in the working chamber, raise the temperature therein up to (20 000 to 40 000) K and the energy density to as high as 109 Jm-3, and form a plasma piston. The alternative development and attenuation of plasma expansion makes the lignite in a number of physical and chemical processes resulting in diverse active radicals and ions, and also breaks it into grains mostly smaller than 250 mm. It is founded by experimental study that the technology can raise the content of nitro-nitrogen by 1.4 to 1.5 times and that of dissoluble organic substances by 5 to 10 times which is probably attributed to the decomposition of the ample germs in the lignite. The calculated power requirement to activate lignite is about (50 to 60) kWht-1. In comparison with muck applied to cucumber cultivation, the activated lignite demonstrates its features as an effective and economical green fertilizer by the same yield with half amount. These findings imply a promising access to green fertilizer.展开更多
Experiments were conducted to study the performance characters of aerobic/anoxic （A/ A） digestion of sludge at 30± 1 ℃, while the sludge retention time （SRT） was kept 16 d. The varia tions of oxidation redu...Experiments were conducted to study the performance characters of aerobic/anoxic （A/ A） digestion of sludge at 30± 1 ℃, while the sludge retention time （SRT） was kept 16 d. The varia tions of oxidation reduction potential （Eh ） and pH were continuously monitored during the A/A di gestion and the conversions of ammonium and nitrate were investigated. Important features on both Eh and pH profiles were identified to develop process control strategy. Since the feature point on Eh profile where d2 Eh/dt^2 =0 is very stable during anoxic cycle, it can be used to determine the end of denitrification. The end of nitrification can be identified according to dpH/dt = 0. A real-time control strategy of A/A digestion of sludge was developed and tested with pH and Eh as control parameters. It is shown that the performance of the real-time control strategy is better than that of a fixed time control strategy. While the real time controlled A/A digestion system can achieve a similar volatile suspended solids （VSS） destruction efficiency of 35.2 % as a continuously aerated system, it im proves the supernatant quality in a shorter aeration time（7. 75 d for a 20 d period）.展开更多
Sedimentation tanks and clarifiers play a significant role in an active sludge system, and the efficiency of the whole system is closely related with the design and operation of the sedimentation tanks. This paper foc...Sedimentation tanks and clarifiers play a significant role in an active sludge system, and the efficiency of the whole system is closely related with the design and operation of the sedimentation tanks. This paper focuses on the sludge concentration in each cross-section of the sedimentation tank. We measured the sludge concentration to explore its distribution inside the tank, carried in-situ tests to research the fluid pattern and real operational rules of the sedimentation tank. We also used the computational fluid dynamics (CFD) software, PHOENICS 3.5, to simulate the solid-liquid two-phase fluid inside the tank and describe the sludge concentration distribution. The numerical results indicate obviously a sludge-water interface and a compression interface inside the sedimentation tank, a stratified sedimentary region with uniform concentration and a compression region with high concentration at the bottom of the tank. Although the simulated concentrations deviated slightly from those of in-situ tests, they were still acceptable for identifying the sludge interfaces and fluid pattern inside a sedimentation tank, which are important parameters for optimizing the tank size and improving the settling efficiency.展开更多
By combining sequencing batch reactor (SBR) activated sludge process and constructed wetland (CW), this study is to achieve the domestic wastewater treatment. Our purpose was to determine the optimum operating paramet...By combining sequencing batch reactor (SBR) activated sludge process and constructed wetland (CW), this study is to achieve the domestic wastewater treatment. Our purpose was to determine the optimum operating parameters of the combined process. The process involved advantages and shortages of SBR and CW. Under normal temperature, the 3rd cycle (SBR’s operation cycle is 8 h: inflow for 1 h, limited aeration for 3 h, sediment for 1 h, outflow for 1 h, and idling for 2 h; CW’s hydraulic retention time (HRT) is 24.8 h and hydraulic loading is 24.5 m3/m2 d) was the best cyclic mode. The effluents can meet the standard GB/T18921-2002: "The reuse of urban recycling water: water quality standard for scenic environment use". In the 3rd cycle, the efficiency of CW was the maximum, and energy consumption of SBR was the minimum. Under the condition of low dissolved oxygen, the removing efficiency of chemical oxygen demand (COD) and ammonia was not affected obviously. Simultaneously, nitrification and denitrification phenomena occured and phosphorus was absorbed obviously.展开更多
Sludge bio-char(SC)and thermal-alkaline treated sludge bio-char(TSC)were prepared from municipal sewage sludge(RS)and thermal-alkaline treated sludge sediments(STAS)through fast pyrolysis under nitrogen existence cond...Sludge bio-char(SC)and thermal-alkaline treated sludge bio-char(TSC)were prepared from municipal sewage sludge(RS)and thermal-alkaline treated sludge sediments(STAS)through fast pyrolysis under nitrogen existence condition to remove cationic red X-GRL(A)and cationic yellow X-6G(B)from aqueous solutions.Results of adsorption experiment show that the adsorption capacities of TSC are better than the adsorption capacities of SC.The highest adsorption capacity of 47.65 mg/g for A and 45.41mg/g for B are obtained by TSC in an isotherm experiment at 2.0 g/L dosage and 25°C temperature.TSC adsorption for the two kinds of cationic dyes can be well fitted by pseudo-second-order kinetics model and Langmuir isotherm model.展开更多
In order to improve the anaerobic digestion efficiency of waste activated sludge（WAS）,a pretreatment procedure should be carried out so as to disrupt the microbial cell structure,thus releasing intracellular organic...In order to improve the anaerobic digestion efficiency of waste activated sludge（WAS）,a pretreatment procedure should be carried out so as to disrupt the microbial cell structure,thus releasing intracellular organic matters.In this paper,a corona discharge triggered by a DC voltage was employed to pre-treat WAS for various time periods under different temperatures.The magnitude of the DC voltage was 4 k V at both negative and positive polarities.The changes in the soluble chemical oxygen demand,phosphorus and nitrogen content,and p H value within the WAS were utilized to estimate the pretreatment performance of the DC corona.It was found that with increasing treatment time,the pretreatment efficiency tends to be reduced.With increased temperature,the pretreatment efficiency appears to be better.It is suggested that the oxidative species and the active particles generated in the corona discharge play an important role in disrupting the microbial cell structure,which is dependent upon the treatment time and the temperature.展开更多
基金supported by the National Natural Science Foundation of China (Nos. 51204179, 51204182)the Natural Science Foundation of Jiangsu Province of China (No. BK20141242)the Fundamental Research Funds for the Central Universities of China (No. 2014XT05)
文摘Coal sludge slurry(CSS) is an alternative fuel and a potential competitive method for sludge reduction.Based on the researches of coal water slurry, we studied CSSs by using a wet-grinding process with different types of regional municipal sludge(sludge) in an orthogonal experiment. The sludge type,sludge mixing proportion, dosage of dispersant, and grinding time were tested in this study. The results show that water content and its occurrence characteristics in the sludge have primary hindering influences on slurry ability. The range of fixed-viscosity concentrations with raw wet sludge is from 50.78%to 44.40%(by weight), while the range is from 53.35% to 51.51%(by weight) with dry sludge. All of the CSSs exhibit shear-thinning behaviors with different variation trends, especially the CSSs with more than 15%(by weight) raw wet sludge in it. Adding the same proportion of raw wet sludge increases the thixotropic properties of CSSs and the highest area of thixotropy loop is 3065 Pa/s, while the highest value of dry sludge is 1798 Pa/s. Hydrophilic group plays an important role in adsorbing water and building three-dimension networks with other particles, which is the main reason for CSS properties.Therefore, the mechanism can be used to find the way for making high quality CSS.
基金the support provided by the Research & Technology Development Project of China National Petroleum Corporation (06A0302)Postdoctor Innovation Funds in Shandong Province (201002039)the Fundamental Research Funds for the Central Universities (27R1204023A)
文摘In this study,an up-flow anaerobic sludge blanket(UASB) reactor was applied to treat the high salinity wastewater from heavy oil production process.At a HRT of ≥24 h,the COD removal reached as high as 65.08% at an influent COD ranging from 350mg/L to 640mg/L.An average of 74.33% oil reduction was also achieved in the UASB reactor at an initial oil concentration between 112mg/L and 205mg/L.These results indicated that this heavy oil production related wastewater could be degraded efficiently in the UASB reactor.Granular sludge was formed in this reactor.In addition,two models,built on the back propagation neural network(BPNN) theory and linear regression techniques were developed for the simulation of the UASB system performance in the oily wastewater biodegradation.The average error of COD and oil removal was-0.65% and 0.84%,respectively.The results indicated that the models built on the BPNN theory were wellfitted to the detected data,and were able to simulate and predict the removal of COD and oil by the UASB reactor.
文摘Crude oil is a kind of water/oil emulsion, which the oil phase consists of organic molecules with different molecular weights such as alkanes, paraffin, asphaltene, and resins. Due to the change in physicochemical conditions during the production, transportation, storage, and refining, heavier molecules can precipitate from crude oil. Thus, viscous sludge formed at the bottom of storage tanks can cause many problems including reduction of storage capacity of tank, oil contamination, corrosion, repair costs, environmental pollution, etc. The reduction of sludge viscosity can be achieved by reduction of its interfacial tension. In this study, different chemical and physical factors, influencing prepared emulsions（made of sludge, water and surfactant）, such as surfactants, solvents, temperature, pressure, and mixing conditions were investigated. Results showed that non-ionic surfactants（like bitumen emulsifier）, and solvents（such as mixed xylene, AW-400, and AW-402）, injection of additives, applying pressure, and mixing operations had a positive effect on reduction of emulsion viscosity. All experiments were carried out with sludge obtained from crude oil storage tanks at Kharg Island,Iran.
文摘A study was carried out to determine the influence of different types of sludges （municipal, industrial and residential） on field germination, growth and nodulation of L. leucocephala seedlings in the nursery. Before sowing of seeds, different combinations of sludges were incorporated with the nutrient deficient natural forest soils. Field germination, nodulation status and physical growth parameters of seedlings （shoot and root length, vigor index, collar diameter, leaf number, fresh and dry weight of shoot and root and total dry biomass increment） were recorded after three and six months of seed sowing. Field germination, nodulation status and growth parameters were varied significantly in the soil amended with sludges in comparison to control. The highest number of nodule was recorded from soil amended with residential sludge （ 1：1 ） and highest fresh and dry nodule weight was also found from the same combination in both three and six month old seedlings. In case of growth parameters, the highest growth was recorded from soil and residential sludge （ 1：1 ） combination compared to control. From the study, it can be recommended that soil amended with residential sludge （ 1：1 ） provide better field germination, growth and nodule formation of L. leucocephala in degraded soil.
基金financially supported by Natural Science Foundation of China (No. 21776307)Science and Technology Major Project of China (No. 2016zx05040)Science Foundation of China University of Petroleum, Beijing (No. 2462018BJB001)
文摘The cost-effective treatment of activated sludge that is generated by refining petroleum is a challenging industrial problem.In this study, semi-continuous stirred tank reactors(CSTRs) containing petroleum refinery excess activated sludge(PREAS)were used to comparatively investigate hydrolysis and acidification rates, after the addition of heneicosane(C_(21)H_(44))(R1)and 1-phenylnaphthalene(C16 H12)(R2) to different and individual reactors. Operation of the reactors using a sludge retention time(SRT) of 6 days and a pH of 5.0, resulted in the maintenance of stable biological activity as determined by soluble chemical oxygen demand(SCOD), volatile fatty acids(VFAs) production and oil removal efficiency. The optimum conditions for hydrogen production include a SRT of 8 days, at pH 6.5. Under these conditions, hydrogen production rates in the control containing only PREAS were 1567 mL/L(R0), compared with 1365 mL/L in Rl and 1454 mL/L-PREAS in R2.Coprothermobacter, Fervidobacterium, Caldisericum and Tepidiphilus were the dominant bacterial genera that have the potential to degrade petroleum compounds and generate VFAs. This study has shown that high concentrations of heneicosane and 1-phenylnaphthalene did not inhibit the hydrolytic acidification of PREAS.
基金supported by the "Special Fund for Forestry Research in the Public Interest(201204802-1)"the "Nature Science Foundation of China(31070506)"
文摘We used paper mill sludge（PMS） to substitute for part of the wood fibers（WF） used to reinforce high density polyethylene（HDPE）.The resulting composites were subjected to xenon-arc weathering.The composite filled with limited PMS（under 10 %） had mechanical properties and aging resistance similar to those without PMS.The composites containing more PMS faded and cracked more readily than those without PMS.Based on the carbonyl index,crystallinity,and wood index,PMS appeared to accelerate the degradation of composites during weathering.Adding PMS to WF–HDPE composites reduced the weathering resistance,and this reduction was not significant if the PMS content did not exceed 20 % of the wood fibers.Therefore,PMS could be used as a reinforcement in wood-plastic composites at levels less than20 % of the wood fiber content.
基金supported by National Key R&D Program of China[NO.2020YFB2010002]National Natural Science Foundation of China[NO.51706247,NO.51975585]the Fundamental Research Funds for the Central Universities and the Opening Fund of National Engineering Laboratory of Offshore Geophysical and Exploration Equipment[NO.20CX02312A]
文摘The disc-seal single screw pump(DSSP)used in the field of high viscosity oily sludge transport has a huge advantage.However,there is no research on the pressurization characteristics of the DSSP at present,which makes its application limited.In view of this,the pressurization process mathematical model of the DSSP was established based on the geometric model of the pump.By using this model,the pressurization characteristics of DSSP and the influence of working parameters on the pressurization process were studied combined with the principle of back-flow pressurization.Analysis results show that the instantaneous pressurization process could be realized mainly depending on the reflux pressurization from the outlet chamber to the pressurization chamber when the screw rotor rotating angle is located at-5°to+5°.The pressure in the pressurization chamber will increase with the increase of working parameters which include inlet pressure,outlet pressure,screw rotation velocity and dynamic viscosity of fluid medium in the area of flow-back pressurization.The screw rotation velocity and the viscosity of the conveying medium have significant effects on the peak pressure in the pressurization chamber,and the peak pressure in the pressurization chamber is proportional to the screw rotation velocity and the dynamic viscosity coefficient of the conveying medium.The proportional coefficient between the peak pressure and the screw rotation velocity is 6.29×10~4.The proportional coefficient between the peak pressure and the dynamic viscosity of the conveying medium is 6.28×10~6.
文摘Thermal plasma was applied for the treatment of coke wastewater sludge derived from the steel industry in order to investigate the feasibility of the safe treatment and energy recovery of the sludge. A 30 kW plasma torch system was applied to study the vitrification and gas production of coke wastewater sludge. Toxicity leaching results indicated that the sludge treated via the thermal plasma process converted into a vitrified slag which resisted the leaching of heavy metals. CO2 was utilized as working gas to study the production and heat energy of the syngas. The heating value of the gas products by thermal plasma achieved 8.43 k J/L, indicating the further utilization of the gas products. Considering the utilization of the syngas and recovery heat from the gas products, the estimated treatment cost of coke wastewater sludge via plasma torch was about 0.98 CNY/kg sludge in the experiment. By preliminary economic analysis, the dehydration cost takes an important part of the total sludge treatment cost. The treatment cost of the coke wastewater sludge with 50 wt.% moisture was calculated to be about 1.45 CNY/kg sludge dry basis. The treatment cost of the coke wastewater sludge could be effectively controlled by decreasing the water content of the sludge. These findings suggest that an economic dewatering pretreatment method could be combined to cut the total treatment cost in an actual treatment process.
文摘A study was conducted to evaluate the effects of sludge （industrial and residential） on seed germination and growth performance of Acacia auriculiformis seedlings at the nursery of Institute of Forestry and Environmental Sciences, Chittagong University （IFESCU）, Bangladesh. Before sowing of the seeds, different combinations of sludge were incorporated with the nutrient-deficient natural forest soils. Seed germination and growth parameters of the seedlings （shoot and root length, collar diameter, fresh and dry weight of shoot, and root and total dry biomass） were recorded after one, two and three months of seed sowing. Physio-chemical parameters （pH, organic carbon, nitrogen, phosphorus, and potassium） and heavy metals （chromium, nickel, manganese, cadmium and zinc） of each treatment were also analyzed before sowing of seeds and after harvesting of seedlings. Results show that the seed germination percentage and the seedling growth parameters varied significantly in the soil added with sludge in comparison to control. The highest germination percentage （90%） was observed in the treatment of soil with residential sludge of 2：1 compared to control. The highest growth and biomass of the seedlings as well as the maximum percentage of organic carbon and nutrients （N, P and K） were also recorded in the same combination. Soil added with industrial sludge had a higher concentration of heavy metal than that of residential sludge. The highest concentrations of heavy metals were found in soil added with industrial sludge of 1：1. It is recommended that soil added with residential sludge of 2：1 provide good condition for better seed germination and growth ofA. auriculiformis seedlings in degraded forest soil.
基金This work was supported by the Future Scientists Program of China University of Mining and Technology(2020WLKXJ019).
文摘Oily sludge was recognized as a kind of hazardous wastes,so recycling its high content of petroleum hydrocarbons can contribute to the clean environment.In this study,oily sludge was subjected to continous ultrasonic extraction with an acetone/carbon disulfide(CS2)mixture solvent.Fourier transform infrared spectroscopy(FTIRS),gas chromatography/mass spectrometry(GC/MS),and Quadrupole exactive Orbitrap mass spectrometry(QPEOTMS)were used to analyze the oil phase compounds from oily sludge.The n-alkanes ranging from C8 to C31 hydrocarbons were detected in oil phase.Compared with the analysis results of GC/MS,more heteroatom-containing compounds(HACOCs)of oil phase such as O3,O4,N2Oo and N3Oo(o=0—3)could be detected by using the QPEOTMS analysis.Overall,these findings will potentially contribute to the clean and efficient utilization of oily sludge.
文摘In this study, Mucuna flagellipes seed extract was applied in the coagulation-flocculation of produced water （PW）. Process parameters such as pH, dosage, and settling time were investigated. Process kinetics was also studied. Instrumental characterization of mucuna seed （MS）, mucuna seed coagulant （MSC）, and post effluent treatment settled sludge （PTSS） were carried out. The optimum decontamination efficiency of 95 % was obtained at 1 g/L MSC dosage, PW pH of 2, and rate constant of 0.0001 （L/g/s）. Characterization results indicated that MS, MSC, and PTSS were of network structure, primitive lat- tice, and thermally stable. It could be concluded that MSC would be potential biomass for the treatment of produced water under the experimental conditions.
基金The research was funded by a NCASI grant to S.T. Gower. Wang CK was supported by Innovated Talent Program of Northeast Forestry University (2004-07)
文摘Safe and economical disposal of paper mill sludge is a key consideration for forest products industry. A study was conducted to examine the effects of amendments of sludge and nutrients on soil surface CO2 flux （Rs） in northern hardwood forests and to quantify the relationship among Rs, soil temperature, and moisture in these stands. The experiment was a randomized complete block design that included sludge-amended, fertilized, and control treatments in sugar maple （Acer saccharum Marsh） dominated hardwood forests in the Upper Peninsula of Michigan, USA. Results showed that Rs was positively correlated to soil temperature （R^2 = 0.80, p 〈 0.001）, but was poorly correlated to soil moisture. Soil moisture positively affected the Rs only in the sludge-amended treatment. The Rs was significantly greater in the sludge-amended treatment than in the fertilized （p = 0.033） and the control （p = 0.048） treatments. The maximum Rs in the sludge-amended treatment was 8.8 μmol CO2 · m^ 2. s^-1, 91% and 126% greater than those in the fertilized （4.6 μmol CO2 · m^-2· s^-1） and control （3.9 μmol CO2· m^- 2· s^-1） treatments, respectively. The Rs did not differ significantly between the fertilized and control treatments. The difference in Rs between sludge-amended and the other treatments decreased with time following treatment.
基金Supported by the National Science&Technology Pillar Program During the 12th Five-Year Plan Period(2014BAC28B01)Beijing Natural Science Foundation(8112012)
文摘Polyhydroxyalkanoates（PHAs）were synthesized in activated sludge using three types of carbon sources（sodium acetate,sodium propionate and sodium butyrate）,and their characterization were studied.It was shown that the content of PHA synthesized by microorganisms in activated sludge were different.The biggest synthetic amount up to 36.7% of VSS was obtained when sodium acetate was used as carbon source.The polymer yield was lower when using sodium propionate as the carbon source than when using others,with25.1% of VSS,while resulted in an increase of hydroxyvalerate（HV）units produced.The structure and thermal properties of extracted biopolymers were analyzed by scanning electron microscope（SEM）,Fourier transform infrared spectroscopy（FTIR）and themogravimetry（TG）.
基金the National Natural Science Foundation of China (59979029)
文摘A device to activate lignite and sludge by electro-hydraulic impulse is presented. It comprises an impulse current generator constituted by a high voltage transformer, a high voltage silicon rectifier, a current-limiting resistor, a capacitor bank and an air-break switch, and a lignite and sludge appliance made up of two plane electrodes and a working chamber. The installation activates the lignite or sludge delivered to the working chamber by the impulse current that is from the generator to puncture the main gap in the working chamber, raise the temperature therein up to (20 000 to 40 000) K and the energy density to as high as 109 Jm-3, and form a plasma piston. The alternative development and attenuation of plasma expansion makes the lignite in a number of physical and chemical processes resulting in diverse active radicals and ions, and also breaks it into grains mostly smaller than 250 mm. It is founded by experimental study that the technology can raise the content of nitro-nitrogen by 1.4 to 1.5 times and that of dissoluble organic substances by 5 to 10 times which is probably attributed to the decomposition of the ample germs in the lignite. The calculated power requirement to activate lignite is about (50 to 60) kWht-1. In comparison with muck applied to cucumber cultivation, the activated lignite demonstrates its features as an effective and economical green fertilizer by the same yield with half amount. These findings imply a promising access to green fertilizer.
基金Supported by the National High Technology Research and Development Program of China("863"Program)(2006AA06Z319)the National Key Technology R&D Programof the 11th Five-Year Plan China(2007BAK36B07)the Research Foundation for Youth Scholars of Beijing Technology and Business University(QNJJ-28)
文摘Experiments were conducted to study the performance characters of aerobic/anoxic （A/ A） digestion of sludge at 30± 1 ℃, while the sludge retention time （SRT） was kept 16 d. The varia tions of oxidation reduction potential （Eh ） and pH were continuously monitored during the A/A di gestion and the conversions of ammonium and nitrate were investigated. Important features on both Eh and pH profiles were identified to develop process control strategy. Since the feature point on Eh profile where d2 Eh/dt^2 =0 is very stable during anoxic cycle, it can be used to determine the end of denitrification. The end of nitrification can be identified according to dpH/dt = 0. A real-time control strategy of A/A digestion of sludge was developed and tested with pH and Eh as control parameters. It is shown that the performance of the real-time control strategy is better than that of a fixed time control strategy. While the real time controlled A/A digestion system can achieve a similar volatile suspended solids （VSS） destruction efficiency of 35.2 % as a continuously aerated system, it im proves the supernatant quality in a shorter aeration time（7. 75 d for a 20 d period）.
基金the Key Subject Supporting Project of Shanghai Government (No. 042312067)
文摘Sedimentation tanks and clarifiers play a significant role in an active sludge system, and the efficiency of the whole system is closely related with the design and operation of the sedimentation tanks. This paper focuses on the sludge concentration in each cross-section of the sedimentation tank. We measured the sludge concentration to explore its distribution inside the tank, carried in-situ tests to research the fluid pattern and real operational rules of the sedimentation tank. We also used the computational fluid dynamics (CFD) software, PHOENICS 3.5, to simulate the solid-liquid two-phase fluid inside the tank and describe the sludge concentration distribution. The numerical results indicate obviously a sludge-water interface and a compression interface inside the sedimentation tank, a stratified sedimentary region with uniform concentration and a compression region with high concentration at the bottom of the tank. Although the simulated concentrations deviated slightly from those of in-situ tests, they were still acceptable for identifying the sludge interfaces and fluid pattern inside a sedimentation tank, which are important parameters for optimizing the tank size and improving the settling efficiency.
基金Funded by Sustainable Water Management Improves Tomorrow’s City’s Health (SWITCH018530)
文摘By combining sequencing batch reactor (SBR) activated sludge process and constructed wetland (CW), this study is to achieve the domestic wastewater treatment. Our purpose was to determine the optimum operating parameters of the combined process. The process involved advantages and shortages of SBR and CW. Under normal temperature, the 3rd cycle (SBR’s operation cycle is 8 h: inflow for 1 h, limited aeration for 3 h, sediment for 1 h, outflow for 1 h, and idling for 2 h; CW’s hydraulic retention time (HRT) is 24.8 h and hydraulic loading is 24.5 m3/m2 d) was the best cyclic mode. The effluents can meet the standard GB/T18921-2002: "The reuse of urban recycling water: water quality standard for scenic environment use". In the 3rd cycle, the efficiency of CW was the maximum, and energy consumption of SBR was the minimum. Under the condition of low dissolved oxygen, the removing efficiency of chemical oxygen demand (COD) and ammonia was not affected obviously. Simultaneously, nitrification and denitrification phenomena occured and phosphorus was absorbed obviously.
文摘Sludge bio-char(SC)and thermal-alkaline treated sludge bio-char(TSC)were prepared from municipal sewage sludge(RS)and thermal-alkaline treated sludge sediments(STAS)through fast pyrolysis under nitrogen existence condition to remove cationic red X-GRL(A)and cationic yellow X-6G(B)from aqueous solutions.Results of adsorption experiment show that the adsorption capacities of TSC are better than the adsorption capacities of SC.The highest adsorption capacity of 47.65 mg/g for A and 45.41mg/g for B are obtained by TSC in an isotherm experiment at 2.0 g/L dosage and 25°C temperature.TSC adsorption for the two kinds of cationic dyes can be well fitted by pseudo-second-order kinetics model and Langmuir isotherm model.
基金financially supported by National Natural Science Foundation of China(Grant No.51677127)
文摘In order to improve the anaerobic digestion efficiency of waste activated sludge（WAS）,a pretreatment procedure should be carried out so as to disrupt the microbial cell structure,thus releasing intracellular organic matters.In this paper,a corona discharge triggered by a DC voltage was employed to pre-treat WAS for various time periods under different temperatures.The magnitude of the DC voltage was 4 k V at both negative and positive polarities.The changes in the soluble chemical oxygen demand,phosphorus and nitrogen content,and p H value within the WAS were utilized to estimate the pretreatment performance of the DC corona.It was found that with increasing treatment time,the pretreatment efficiency tends to be reduced.With increased temperature,the pretreatment efficiency appears to be better.It is suggested that the oxidative species and the active particles generated in the corona discharge play an important role in disrupting the microbial cell structure,which is dependent upon the treatment time and the temperature.
